Calcium sulfate (gypsum) scaling in nanofiltration of agricultural drainage water

Reclamation and reuse of agricultural tile drainage water in the San Joaquin Valley, California, by membrane desalination has been given serious consideration for nearly 30 years. The agricultural drainage water has very high levels of calcium and sulfate ions, rendering it nearly saturated with gypsum in some locations in this region. The present paper focuses on the conditions of membrane surface gypsum scale formation during nanofiltration (NF) of agricultural drainage water. Experimental studies with drainage water samples and model solutions were conducted in laboratory glassware as well as with a small plate-and-frarne cross-flow membrane re-circulation unit. NF membrane experiments consisted of two types: permeate disposal to measure the effect of increasing recovery on the onset of scaling, and feed water re-circulation at a fixed concentration factor to establish performance change over time. An expression relating NF product water recovery to feed water concentration factor enabled numerous membrane scale formation studies that have direct relevance to full-scale NF systems. Glassware experiments showed that magnesium ions decreased the amount of gypsum incipient nuclei because of MgSO40 complexation, which reduces the availability of sulfate ions for nucleus formation. In membrane experiments, model solutions showed that bicarbonate, magnesium ions, and humic acid retarded the onset of gypsum scaling by tying up calcium ions that would have otherwise been used for formation of gypsum incipient nuclei. Both calcium carbonate and gypsum scales may result from particulate deposition rather than membrane surface (wall) crystallization, with the likelihood of particulate fouling increasing with supersaturation. (C) 2002 Elsevier Science B.V. All rights reserved.