Extraction of active ingredients from green tea (Camellia sinensis):: Extraction efficiency of major catechins and caffeine

The effect of different extraction set-ups that influence the extraction efficiency of catechins and caffeine from green tea leaves (variety Fanning Belas, China) were studied using different aqueous and pure solvents (acetone, ethanol, methanol, acetonitrile, water), different temperatures (60, 80, 95 and 100 degrees C) and times (5-240 min). Raw extracts were analysed for contents of major catechins (EC, EGC, ECG, EGCG), caffeine, proanthocyanidins and flavonols (myricetin, caempherol, quercetin). Starting material was found to contain 191 g major catechins/kg material, 36 g caffeine/kg material and 5.2 g flavonols/kg material on a dry mass basis. The content of major catechins in green tea extracts varied from approximately 280-580 g/kg dry extract, with extraction efficiencies of major catechins varying from 61% to almost 100%. Content of caffeine in extract was in the range of 75 g/kg, where its extraction efficiency varied from 62% to 76%. Average extraction yield was 30% with exceptions when using pure acetone and acetonitrile, where extraction yield was about 3%. Contents of flavonols and proanthocyanidins were in the ranges 6-20 and 12-19 g/kg, respectively. Different extraction procedures with water were also investigated and optimal conditions determined: maximum achieved extraction efficiency of catechins with water was obtained at 80 degrees C after 20 min (97%) and at 95 degrees C after 10 min of extraction (90%). Degradation of catechins was observed at higher extraction temperatures and with prolonged extraction times. Using a lower ratio of solvent to material, extraction efficiencies were increased by applying a multi-step extraction procedure. Optimal extraction procedure was then performed using decaffeinated green tea leaves, which were obtained by high-pressure extraction with CO2, when 98% of caffeine was selectively isolated without significant impact on valuable catechins. (C) 2005 Elsevier Ltd. All rights reserved.