Detection and confirmation of staphylococcal enterotoxin B in apple juice and milk using piezoelectric-excited millimeter-sized cantilever sensors at 2.5 fg/mL

A sensitive and reliable method for the detection of a model toxin, staphylococcal enterotoxin B (SEB) in buffer, apple juice, and milk is shown using piezoelectric-excited, millimeter-sized cantilever (PEMC) sensors. Limit of detection in spiked milk and apple juice samples is 10 and 100 fg, respectively. PEMC sensors (2 mm(2)) are prepared by immobilizing a polyclonal antibody specific to SEB, which was exposed to 1 mL of 1% milk and apple juice containing 10 fg-10 ng. Sensor response to 100 fg, 1 pg, and 10 pg of SEB in apple juice resulted in resonance frequency decreases of 113 +/not superset of 18 (n = 4), 308 +/not superset of 24 (n = 4), and 521 +/not superset of 20 (n = 2) Hz, respectively. In milk, 10 fg, 100 fg, I pg, and 10 pg of SEB resulted in resonance frequency decreases of 126 +/not superset of 18 (n = 2), 143 +/not superset of 35 (n = 4), 310 +/not superset of 32 (n = 5), and 557 +/not superset of 25 (n = 2) Hz, respectively. Positive detection of SEB in the sample solution was observed within the first 20 min. The responses of the sensor to positive (SEB present, but no antibody on sensor), negative (SEB absent, antibody on sensor), and buffer (SEB absent, antibody on sensor) controls were - 17 +/not superset of 10 (n = 3), -9 +/not superset of 5 (n = 3), and -6 +/not superset of 12 (n = 18) Hz, respectively. Positive verification of SEB detection was confirmed by two methods: (1) low-pH buffer release caused increase in resonance frequency, and (2) second antibody binding to SEB attached to sensor that caused further resonance frequency decrease. The significance of these results is that PEMC sensors can reliably detect SEB at 10-100 fg (effective concentration of 2.5 and 25 fg/mL) in complex fluids without sample preparation or the use of labeled reagents.