☆ 4.6 Article

Multistep Improvement of Pilot-Scale 21700 Cells for Increased Fast-Charging Capability: Combining Optimized Electrolyte, Cell Design and Fast-Charging Protocol

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2023)

相关参考文献

注意：仅列出部分参考文献，下载原文获取全部文献信息。

Article Chemistry, Physical

Fluorine-free water-based Ni-rich positive electrodes and their performance in pouch- and 21700-type cells

S. Radloff et al.

Summary: Substantial progress has been made in the lab-scale aqueous processing of Ni-rich cathode electrodes, and now it needs to be proven in production-scale to deliver competitive performance cells. This study successfully scaled up a carboxymethyl cellulose and styrene-butadiene rubber based electrode-coating recipe from lab-scale to production-scale, demonstrating homogeneous mass loading and excellent processability. Challenges such as slurry pH control and mixing/coating time adjustment were overcome. The pilot-scale cathode electrodes with high areal capacities were tested in pouch and cylindrical cells, showing promising capacity retention after thousands of cycles.

JOURNAL OF POWER SOURCES (2023)

添加到收藏夹

Article Chemistry, Physical

Direct observation of internal short circuits by lithium dendrites in cross-sectional lithium-ion in situ full cells

Christin Hogrefe et al.

Summary: Li metal deposition and internal short circuits in full cells are observed using in situ optical microscopy. Different conditions and effects, such as lithiation gradients, dendrite growth, dissolution rate, self-discharge, and the importance of separator pores, are discussed.

JOURNAL OF POWER SOURCES (2023)

添加到收藏夹

Article Energy & Fuels

Effects of Tab Design in 21700 Li-Ion Cells: Improvements of Cell Impedance, Rate Capability, and Cycling Aging

Thomas Waldmann et al.

Summary: In this study, the tab design of Li-ion cells with the industrially relevant 21700 format was experimentally investigated. The effects of tab design on cell performance were observed through systematic variation of the tab design. The results showed that cells with a multitab design exhibited reduced impedance, improved charging rate capability, increased cycle stability, and enhanced charge throughput. X-ray computed tomography revealed that the improved cycle life was attributed to the reduction of inhomogeneities in the jellyrolls. Comparative analysis with cells from other studies provided insights into the magnitude of the effects of tab design variation.

ENERGY TECHNOLOGY (2023)

添加到收藏夹

Article Electrochemistry

Interfacial kinetics and low-temperature behavior of spheroidized natural graphite particles as anode for Li-ion batteries

Irene Ruggeri et al.

Summary: The research indicates that different milling conditions significantly affect the rate of Li+ intercalation and the kinetics of charge-transfer reaction. The surface properties of graphite particles mainly determine the rate of lithiation reaction, with particles containing a large amount of prismatic and defect-rich surfaces promoting faster Li+ intercalation.

JOURNAL OF SOLID STATE ELECTROCHEMISTRY (2022)

添加到收藏夹

Article Electrochemistry

Influence of Laser Structuring and Calendering of Graphite Anodes on Electrode Properties and Cell Performance

Lucas Hille et al.

Summary: This study explores the influence of calendering and laser structuring on the pore structure and electrochemical performance of electrodes. Laser structuring was found to release superficial pore clogging caused by calendering and to result in binder agglomerates on the electrode surfaces. Structured electrodes showed higher porosities than unstructured counterparts, but no significant change in the pore size distribution was detected. Electrochemical impedance spectra revealed increasing ionic resistances and tortuosities for decreasing electrode porosities. Laser structuring significantly reduced the diffusion limitations of lithium-ion at all porosity levels. Furthermore, electrode structuring showed potential for improving performance at high currents.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2022)

添加到收藏夹

Article Electrochemistry

Cross-Sectional In Situ Optical Microscopy with Simultaneous Electrochemical Measurements for Lithium-Ion Full Cells

Christin Hogrefe et al.

Summary: This study introduces a new in situ optical microscopy set-up that enables direct observation of cross-sections of Li-ion full cells while recording electrochemical data. The method allows insights into processes at the electrode and particle level, and enables evaluation of lithiation fronts speed, diffusion coefficients, electrical de-contacting and re-contacting of single graphite particles, as well as electrode thickness changes.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2022)

添加到收藏夹

Article Chemistry, Physical

Improving the ionic transport properties of graphite anodes for lithium ion batteries by surface modification using nanosecond laser

J. Sandherr et al.

Summary: Ion transport limitation is a well-known problem that occurs when the energy density of a battery is increased. In this study, a pulsed nanosecond laser machining method is proposed, which aims at material-preserving surface treatment of the electrodes. The method improves the rate capability of the electrodes and reduces cell overpotentials.

JOURNAL OF POWER SOURCES (2022)

添加到收藏夹

Article Chemistry, Physical

Arrhenius plots for Li-ion battery ageing as a function of temperature, C-rate, and ageing state – An experimental study

Gints Kucinskis et al.

JOURNAL OF POWER SOURCES (2022)

添加到收藏夹

Review Engineering, Electrical & Electronic

Charging Optimization for Li-Ion Battery in Electric Vehicles: A Review

Cuili Chen et al.

Summary: This article provides a comprehensive review of existing charging optimization techniques for lithium-ion batteries, addressing the challenges of long charging time and degradation caused by fast charging. It discusses the operation and models of lithium-ion batteries and scrutinizes the side effects of unregulated fast charging on battery aging mechanism. The state-of-the-art open- and close-loop charging optimization techniques are systematically reviewed, highlighting their respective merits and shortcomings. The future development of a charging control protocol with real-time affordability and degradation consciousness is also discussed.

IEEE TRANSACTIONS ON TRANSPORTATION ELECTRIFICATION (2022)

添加到收藏夹

Article Electrochemistry

Enabling Fast-Charging Lithium-Ion Battery Anodes: Influence of Spheroidization on Natural Graphite

Marilena Mancini et al.

Summary: Excellent fast-charging performance is crucial for lithium-ion batteries used in automotive applications. This study investigates the rational particle design for active materials within electrodes to minimize kinetic limitations, particularly in the anode. The research shows that the surface and bulk particle properties are strongly influenced by the spheroidization conditions, which in turn affect the electrochemical performance, especially the lithium-intercalation rate. The findings demonstrate the importance of optimizing particle characteristics during spheroidization in developing fast-charging lithium-ion batteries.

BATTERIES & SUPERCAPS (2022)

添加到收藏夹

Article Engineering, Chemical

Increase of Cycling Stability in Pilot-Scale 21700 Format Li-Ion Cells by Foil Tab Design

Thomas Waldmann et al.

Summary: Comparing welded tabs and foil tabs on Li-ion cells in the 21700 format reveals that the cells with foil tabs exhibit 14.4% longer cycling stability and 11.2% increased total charge throughput until 80% SOH, likely due to less inhomogeneities in the case of the foil tab design.

PROCESSES (2021)

添加到收藏夹

Article Electrochemistry

A Direct Comparison of Pilot-Scale Li-Ion Cells in the Formats PHEV1, Pouch, and 21700

Thomas Waldmann et al.

Summary: In this study, Li-ion cells of industrially-relevant formats, including PHEV1 (prismatic), multi-layer pouch, and 21700 (cylindrical), were directly compared for the first time. Despite using the same materials and configurations, these cell formats showed differences in capacities, volume/surface ratios, and configurations, with various parameters such as formation processes, discharge rate capabilities, and geometrical properties being compared to provide insights into their performance. The data were also compared with cells from other studies to provide a comprehensive analysis.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2021)

添加到收藏夹

Review Chemistry, Physical

Fast Charging of Lithium-Ion Batteries: A Review of Materials Aspects

Manuel Weiss et al.

Summary: Fast charging is essential for the economic success of electric vehicles, with lithium-ion batteries facing limitations due to the transport of lithium ions within the electrodes. Understanding these limitations is crucial for optimizing material properties for fast-charging applications.

ADVANCED ENERGY MATERIALS (2021)

添加到收藏夹

Article Energy & Fuels

Ultrafast charging of energy-dense lithium-ion batteries for urban air mobility

Teng Liu et al.

Summary: This study demonstrates an energy-dense lithium-ion battery with ultralong cycle life and ultrafast charging achieved through the asymmetric temperature modulation method. An experimentally validated model quantitatively captures lithium plating during fast charging, effectively increasing usable capacity and energy density of the battery.

ETRANSPORTATION (2021)

添加到收藏夹

Article Electrochemistry

Fast Charging of Li-Ion Cells: Part V. Design and Demonstration of Protocols to Avoid Li-Plating

Ilya A. Shkrob et al.

Summary: Fast charging of Li-ion batteries faces challenges with Li plating on the graphite anode, but can be mitigated by using a variable-rate anode potential charging protocol with a microprobe reference electrode. Experimental data and electrochemical modeling show that high charging rates can still be achieved without risking Li plating within normal operating conditions.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2021)

添加到收藏夹

Article Engineering, Electrical & Electronic

Optimal Multistage Charging of NCA/Graphite Lithium-Ion Batteries Based on Electrothermal-Aging Dynamics

Xiaosong Hu et al.

IEEE TRANSACTIONS ON TRANSPORTATION ELECTRIFICATION (2020)

添加到收藏夹

Article Chemistry, Physical

Efficient fast-charging of lithium-ion batteries enabled by laser-patterned three-dimensional graphite anode architectures

Kuan-Hung Chen et al.

JOURNAL OF POWER SOURCES (2020)

添加到收藏夹

Article Chemistry, Applied

Superior fast-charging capability of graphite anode via facile surface treatment for lithium-ion batteries

Jisu Kim et al.

MICROPOROUS AND MESOPOROUS MATERIALS (2020)

添加到收藏夹

Article Electrochemistry

Impact of Electrode and Cell Design on Fast Charging Capabilities of Cylindrical Lithium-Ion Batteries

J. Sturm et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2020)

添加到收藏夹

Article Electrochemistry

Influence of the Electrolyte Salt Concentration on the Rate Capability of Ultra-Thick NCM 622 Electrodes

Lea Sophie Kremer et al.

BATTERIES & SUPERCAPS (2020)

添加到收藏夹

Article Electrochemistry

4-Electrode Full Cells for Operando Li+ Activity Measurements and Prevention of Li Deposition in Li-Ion Cells

Bjoern-Ingo Hogg et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2020)

添加到收藏夹

Article Electrochemistry

Enabling fast charging of high energy density Li-ion cells with high lithium ion transport electrolytes

Zhijia Du et al.

ELECTROCHEMISTRY COMMUNICATIONS (2019)

添加到收藏夹

Article Chemistry, Physical

Fast charging of an electric vehicle lithium-ion battery at the limit of the lithium deposition process

Johannes Sieg et al.

JOURNAL OF POWER SOURCES (2019)

添加到收藏夹

Article Electrochemistry

Modeling and Simulation of Pore Morphology Modifications using Laser-Structured Graphite Anodes in Lithium-Ion Batteries

Ludwig Kraft et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2019)

添加到收藏夹

Article Electrochemistry

Requirements for Enabling Extreme Fast Charging of High Energy Density Li-Ion Cells while Avoiding Lithium Plating

Andrew M. Colclasure et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2019)

添加到收藏夹

Article Chemistry, Multidisciplinary

Energy landscape of the charge transfer reaction at the complex Li/SEI/electrolyte interface

Yunsong Li et al.

ENERGY & ENVIRONMENTAL SCIENCE (2019)

添加到收藏夹

Article Chemistry, Physical

Asymmetric Temperature Modulation for Extreme Fast Charging of Lithium-Ion Batteries

Xiao-Guang Yang et al.

JOULE (2019)

添加到收藏夹

Review Electrochemistry

Critical Review of the Use of Reference Electrodes in Li-Ion Batteries: A Diagnostic Perspective

Rinaldo Raccichini et al.

BATTERIES-BASEL (2019)

添加到收藏夹

Article Electrochemistry

Fast Charging of Li-Ion Cells: Part I. Using Li/Cu Reference Electrodes to Probe Individual Electrode Potentials

Marco-Tulio F. Rodrigues et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2019)

添加到收藏夹

Article Energy & Fuels

Optimal Charge Pattern for the High-Performance Multistage Constant Current Charge Method for the Li-Ion Batteries

Abdul Basit Khan et al.

IEEE TRANSACTIONS ON ENERGY CONVERSION (2018)

添加到收藏夹

Article Electrochemistry

Quantifying Inhomogeneity of Lithium Ion Battery Electrodes and Its Influence on Electrochemical Performance

Simon Mueller et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2018)

添加到收藏夹

Article Electrochemistry

Increasing the Discharge Rate Capability of Lithium-Ion Cells with Laser-Structured Graphite Anodes: Modeling and Simulation

Jan B. Habedank et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2018)

添加到收藏夹

Article Energy & Fuels

The Impact of Pulse Charging Parameters on the Life Cycle of Lithium-Ion Polymer Batteries

J. M. Amanor-Boadu et al.

ENERGIES (2018)

添加到收藏夹

Article Electrochemistry

Exploring Classes of Co-Solvents for Fast-Charging Lithium-Ion Cells

David S. Hall et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2018)

添加到收藏夹

Article Electrochemistry

Identifying the limiting electrode in lithium ion batteries for extreme fast charging

Chengyu Mao et al.

ELECTROCHEMISTRY COMMUNICATIONS (2018)

添加到收藏夹

Article Electrochemistry

Understanding limiting factors in thick electrode performance as applied to high energy density Li-ion batteries

Zhijia Du et al.

JOURNAL OF APPLIED ELECTROCHEMISTRY (2017)

添加到收藏夹

Proceedings Paper Physics, Applied

Analysis of effective pulse current charging method for lithium ion battery

N. Majid et al.

2ND INTERNATIONAL SYMPOSIUM ON FRONTIER OF APPLIED PHYSICS (ISFAP 2016) (2017)

添加到收藏夹

Article Electrochemistry

Optimizing Areal Capacities through Understanding the Limitations of Lithium-Ion Electrodes

Kevin G. Gallagher et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2016)

添加到收藏夹

Article Chemistry, Physical

Characterization of graphite etched with potassium hydroxide and its application in fast-rechargeable lithium ion batteries

Jae-Hyun Shim et al.

JOURNAL OF POWER SOURCES (2016)

添加到收藏夹

Article Electrochemistry

Direct Electrochemical Determination of Thermodynamic Factors in Aprotic Binary Electrolytes

Johannes Landesfeind et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2016)

添加到收藏夹

Article Electrochemistry

Interplay of Operational Parameters on Lithium Deposition in Lithium-Ion Cells: Systematic Measurements with Reconstructed 3-Electrode Pouch Full Cells

Thomas Waldmann et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2016)

添加到收藏夹

Article Multidisciplinary Sciences

Lithium-ion battery structure that self-heats at low temperatures

Chao-Yang Wang et al.

NATURE (2016)

添加到收藏夹

Article Energy & Fuels

Magnetically aligned graphite electrodes for high-rate performance Li-ion batteries

Juliette Billaud et al.

NATURE ENERGY (2016)

添加到收藏夹

Article Energy & Fuels

Charging protocols for lithium-ion batteries and their impact on cycle life-An experimental study with different 18650 high-power cells

Peter Keil et al.

JOURNAL OF ENERGY STORAGE (2016)

添加到收藏夹

Article Electrochemistry

Optimization of Charging Strategy by Prevention of Lithium Deposition on Anodes in high-energy Lithium-ion Batteries - Electrochemical Experiments

Thomas Waldmann et al.

ELECTROCHIMICA ACTA (2015)

添加到收藏夹

Article Electrochemistry

In-Situ Detection of Lithium Plating Using High Precision Coulometry

J. C. Burns et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2015)

添加到收藏夹

Article Electrochemistry

Tool for Tortuosity Estimation in Lithium Ion Battery Porous Electrodes

Martin Ebner et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2015)

添加到收藏夹

Article Electrochemistry

Microscopic observations of the formation, growth and shrinkage of lithium moss during electrodeposition and dissolution

Jens Steiger et al.

ELECTROCHIMICA ACTA (2014)

添加到收藏夹

Article Electrochemistry

Impedance Spectra of Energy-Storage Electrodes Obtained with Commercial Three-Electrode Cells: Some Sources of Measurement Artefacts

Mikhael D. Levi et al.

ELECTROCHIMICA ACTA (2014)

添加到收藏夹

Article Chemistry, Physical

Low-temperature charging of lithium-ion cells part I: Electrochemical modeling and experimental investigation of degradation behavior

Simon Tippmann et al.

JOURNAL OF POWER SOURCES (2014)

添加到收藏夹

Article Chemistry, Physical

Physical characterization of the charging process of a Li-ion battery and prediction of Li plating by electrochemical modelling

N. Legrand et al.

JOURNAL OF POWER SOURCES (2014)

添加到收藏夹

Article Chemistry, Physical

Temperature dependent ageing mechanisms in Lithium-ion batteries - A Post-Mortem study

Thomas Waldmann et al.

JOURNAL OF POWER SOURCES (2014)

添加到收藏夹

Article Chemistry, Physical

Low-temperature charging of lithium-ion cells Part II: Model reduction and application

Juergen Remmlinger et al.

JOURNAL OF POWER SOURCES (2014)

添加到收藏夹

Article Chemistry, Physical

Effect of cathode/anode area ratio on electrochemical performance of lithium-ion batteries

Bongki Son et al.

JOURNAL OF POWER SOURCES (2013)

添加到收藏夹

Review Electrochemistry

Separator technologies for lithium-ion batteries

Xiaosong Huang

JOURNAL OF SOLID STATE ELECTROCHEMISTRY (2011)

添加到收藏夹

Article Chemistry, Physical

Direct in situ measurements of Li transport in Li-ion battery negative electrodes

Stephen J. Harris et al.

CHEMICAL PHYSICS LETTERS (2010)

添加到收藏夹

Article Automation & Control Systems

Search for an Optimal Rapid-Charging Pattern for Li-Ion Batteries Using the Taguchi Approach

Yi-Hwa Liu et al.

IEEE TRANSACTIONS ON INDUSTRIAL ELECTRONICS (2010)

添加到收藏夹

Article Electrochemistry

Two-Dimensional Modeling of Lithium Deposition during Cell Charging

Maureen Tang et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2009)

添加到收藏夹

Review Engineering, Chemical

Critical review of the impact of tortuosity on diffusion

Lihua Shen et al.

CHEMICAL ENGINEERING SCIENCE (2007)

添加到收藏夹

Article Chemistry, Physical

The effect of the charging protocol on the cycle life of a Li-ion battery

Sheng Shui Zhang

JOURNAL OF POWER SOURCES (2006)

添加到收藏夹

Article Chemistry, Physical

Boostcharging Li-ion batteries: A challenging new charging concept

PHL Notten et al.

JOURNAL OF POWER SOURCES (2005)

添加到收藏夹

Article Chemistry, Physical

Multi-step constant-current charging method for an electric vehicle nickel/metal hydride battery with high-energy efficiency and long cycle life

T Ikeya et al.

JOURNAL OF POWER SOURCES (2002)

添加到收藏夹

Article Electrochemistry

Change of conductivity with salt content, solvent composition, and temperature for electrolytes of LiPF6 in ethylene carbonate-ethyl methyl carbonate

MS Ding et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2001)

添加到收藏夹

© Peeref 2019-2024. All rights reserved.