☆ 4.7 Article

Study on the structure-activity relationship of alcohol in ilmenite flotation with benzohydroxamic acid/alcohol as mixed collectors

APPLIED SURFACE SCIENCE (2024)

相关参考文献

注意：仅列出部分参考文献，下载原文获取全部文献信息。

Article Chemistry, Physical

Depression mechanisms of sodium humate and 3-mercaptopropionic acid on pyrite in fine coal flotation

Chengyong Wang et al.

Summary: Pyrite in coal causes serious environmental pollution in the utilization of coal. Flotation is an appropriate method to remove pyrite present in fine coal, and sodium humate (HA-Na) and 3-mercaptopropionic acid (3-MPA) can be used as depressants for pyrite removal. Molecular dynamics simulation investigates the depression mechanisms of HA-Na and 3-MPA. Results show that HA-Na has a better effect on reducing sulfur content in flotation cleaned coal, while 3-MPA has a stronger selectivity in removing pyrite.

APPLIED SURFACE SCIENCE (2023)

添加到收藏夹

Article Chemistry, Physical

The inhibiting effect of sulfuric acid pretreatment in the flotation of new low-TiO2 ilmenite: Surface property and adsorption mechanism

Qingyou Meng et al.

Summary: In the industrial flotation separation process, the floatability of new low-TiO2 ilmenite is higher than that of common ilmenite, resulting in a decrease in the TiO2 grade of the final concentrate. It has been found that sulfuric acid pretreatment can improve the floatability of common ilmenite. However, this study discovered that sulfuric acid pretreatment decreases the floatability of new low-TiO2 ilmenite. The changes in NaOL adsorption and surface hydrophobicity of low-TiO2 ilmenite after acid surface pretreatment were responsible for the reduction in its flotation recovery.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2023)

添加到收藏夹

Article Chemistry, Physical

Molecular characteristics of the mixed cationic/anionic collector interface probed by sum-frequency vibrational spectroscopy and molecular dynamics simulations

Guangli Zhu et al.

Summary: This study investigates the molecular structure and orientation of mixed dodecylamine hydrochloride (DDA) and sodium oleate (NaOL) collectors and water molecules at the air/water interface. Surface pressure measurements, sum frequency vibrational spectroscopy (SFVS), and molecular dynamics (MD) simulations were conducted to characterize the interface. The results show that individual NaOL and DDA collectors exhibit good ordering at the interface, while mixed collector systems may have gauche defects. Increasing the molar ratio of NaOL to DDA enhances the ordering of interfacial water molecules. The study provides insight into the flotation phenomena and molecular characteristics of collectors, contributing to the improvement of froth flotation technology.

JOURNAL OF MOLECULAR LIQUIDS (2023)

添加到收藏夹

Article Engineering, Chemical

Adsorption differences and mechanism of Pb-BHA and Al-BHA in the flotation separation of ilmenite and titanaugite

Wei Xiao et al.

Summary: In this study, the adsorption differences between Pb-BHA and Al-BHA during the flotation separation of ilmenite from titanaugite were compared and explained using various assays. The results showed that both metal ion chelate collectors significantly increased the ilmenite flotation recovery, with no major effect on titanaugite. In the mixed ore test, Pb-BHA exhibited good collection ability, while Al-BHA showed excellent selectivity.

MINERALS ENGINEERING (2023)

添加到收藏夹

Article Engineering, Chemical

Investigation of the effect of phosphoric acid as an acidic medium in flotation separation of dolomite from magnesite

Lev O. Filippov et al.

Summary: Flotation separation of carbonate minerals is challenging due to their similar surface properties. This study explored the flotation of dolomite and magnesite under acidic to neutral pH conditions using oleate as collector and hydrochloric acid or phosphoric acid as pH regulator. It was found that the recovery of dolomite was unaffected by pH, whereas the recovery of magnesite decreased with acid addition, particularly when phosphoric acid was used. The results indicated that dolomite had a higher dissolution rate than magnesite at acidic pH, providing more calcium ions for interaction with the oleate collector. The findings were supported by infrared spectroscopic analysis, which showed a greater amount of oleate adsorption/precipitation on dolomite compared to magnesite. Furthermore, the presence of new PO4 species in the Raman and infrared spectra of these minerals at acidic pH suggested a potential surface passivation of magnesite, explaining the decrease in magnesite flotation when phosphoric acid was used as pH control.

MINERALS ENGINEERING (2023)

添加到收藏夹

Article Engineering, Chemical

Effect of the adding order of sulfuric acid on the flotation behaviors of ilmenite and titanaugite and its functional mechanism

Yusheng Du et al.

Summary: The influence of changing the adding order of sulfuric acid (H2SO4) and sodium oleate (NaOL) on the flotation of ilmenite and titanaugite was investigated. The experiments showed that adding NaOL first improved the recovery of ilmenite and reduced the recovery of titanaugite, while decreasing the dosage of H2SO4. Analysis indicated that the total ions caused by H2SO4 prevented the adsorption of NaOL on ilmenite surfaces, but had little effect on titanaugite. However, when NaOL was added first, it weakened the dissolution of H2SO4 on ilmenite surfaces, but was destroyed by the dissolution of H2SO4 on titanaugite surfaces. Therefore, altering the adding order of H2SO4 and NaOL reinforced the adsorption difference of NaOL on ilmenite and titanaugite surfaces. This was supported by contact angle, zeta potential, and AFM analyses.

MINERALS ENGINEERING (2023)

添加到收藏夹

Article Chemistry, Physical

Flotation and adsorption characteristics of albite and quartz with oleic acid-based collector

Savas Ozun et al.

Summary: The separation of feldspars from quartz is challenging due to their similar physical and surface properties. This study aimed to determine the flotation behavior and adsorption characteristics of both minerals using an oleic acid-based collector. The results showed that the collector-treated albite exhibited stronger adsorption FTIR bands compared to quartz, and selective flotation recovery was observed in an alkaline environment. AFM analysis further revealed different adsorption patches on collector-treated albite, indicating collector adsorption, while quartz showed no/low collector interaction.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2023)

添加到收藏夹

Article Engineering, Environmental

Effect of goethite (& alpha;-FeOOH) nanoparticles on the surface properties and flotation behavior of chalcopyrite

Gde Pandhe Wisnu Suyantara et al.

Summary: Chalcopyrite flotation can be selectively depressed by oxidation treatment. The presence of ferric oxyhydroxide on the surface of chalcopyrite after oxidation treatment is a key factor in depressing chalcopyrite flotation. Goethite (α-FeOOH) nanoparticles were found to physically adsorb on the chalcopyrite surface and render it hydrophilic, thereby reducing the chalcopyrite flotation recovery.

JOURNAL OF ENVIRONMENTAL CHEMICAL ENGINEERING (2023)

添加到收藏夹

Article Engineering, Chemical

Separation mechanism of ilmenite from titanaugite with mixed BHA/NaOL collector

Qingyou Meng et al.

Summary: The mixed BHA/NaOL surfactant was found to have a higher floatability for ilmenite compared to titanaugite, achieving 86.50% recovery and 39.42% TiO2 grade in artificially mixed mineral experiments. Results from zeta potential, AFM, and XPS analyses showed that the mixed BHA/NaOL interacted with specific active sites on the ilmenite surface, forming a stable hydrophobic layer. Simulation results indicated that the collectors substituted water molecules on the ilmenite surface, contributing to the floatability difference between ilmenite and titanaugite.

MINERALS ENGINEERING (2022)

添加到收藏夹

Article Metallurgy & Metallurgical Engineering

Selective depression mechanism of combination of lime and sodium humate on arsenopyrite in flotation separation of Zn-As bulk concentrate

Qian Wei et al.

Summary: The combined depressant of CaO and NaHA can selectively depress arsenopyrite, achieving effective separation of sphalerite and arsenopyrite. Experimental results demonstrate that the synergistic effect of CaO and NaHA has a satisfactory flotation separation performance.

TRANSACTIONS OF NONFERROUS METALS SOCIETY OF CHINA (2022)

添加到收藏夹

Article Chemistry, Physical

Effect of lead ions on the selective flotation of ilmenite against titanaugite using octyl hydroxamic acid as collector

Li Yu et al.

Summary: This study investigated the adsorption behavior of lead ions on the surfaces of ilmenite and titanaugite, and found that it significantly influenced the flotation behavior of ilmenite. Through chemisorption and physisorption, lead ions could enhance the floatability of ilmenite, while having no effect on the floatability of titanaugite.

APPLIED SURFACE SCIENCE (2022)

添加到收藏夹

Article Chemistry, Physical

Underlying synergistic collection mechanism of an emerging mixed reagent scheme in chalcopyrite flotation

Song Zou et al.

Summary: In this study, a novel reagent system consisting of IPETC and BEAT collectors was developed to improve the flotation recovery of chalcopyrite. The results showed that the mixed collectors exhibited superior foaming properties, better water solubility, stronger hydrophobicity, and greater selectivity towards chalcopyrite. The interaction between the mixed collectors and chalcopyrite surface was chemically involved, leading to a positive synergistic effect.

JOURNAL OF MOLECULAR LIQUIDS (2022)

添加到收藏夹

Article Engineering, Chemical

Activation of ilmenite flotation by Al3+ in the benzohydroxamic acid (BHA) system

Wei Xiao et al.

Summary: This study developed a new scheme to activate ilmenite using Al3+ in a benzohydroxamic acid (BHA) system, and the results showed that the Al-BHA complexes had great potential to enhance ilmenite flotation in BHA system.

SEPARATION AND PURIFICATION TECHNOLOGY (2022)

添加到收藏夹

Article Chemistry, Physical

Investigations on the synergistic effect of combined NaOl/SPA collector in ilmenite flotation

Siyuan Yang et al.

Summary: The study found that the combined collector of NaOl and SPA in ilmenite flotation has a synergistic effect, leading to improved adsorption energy and collection performance.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2021)

添加到收藏夹

Article Chemistry, Physical

New insights for improving ilmenite flotation via surface modification with lead ions

Xuan Zhao et al.

Summary: The research illustrated the adsorption behavior of lead ions on ilmenite surface and found that lead ions activated ilmenite flotation by promoting the adsorption of sodium oleate, leading to a positive shift of surface charge and an increase in surface active sites. The Pb(OH)(+) was identified as the main active species on activating ilmenite flotation, adsorbing onto O, Fe, and Ti surface sites on ilmenite through the bridging action of the O atom.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2021)

添加到收藏夹

Article Chemistry, Physical

Influence of Fe-BHA complexes on the flotation behavior of ilmenite

Pan Chen et al.

Summary: The research demonstrates that Fe-BHA complexes can effectively improve the floatability of ilmenite by promoting the adsorption of BHA on its surface, resulting in increased flotation recovery. The XPS analysis suggests that Fe-BHA complexes may react with the hydroxylated ilmenite surface to form new chemical bonds, Ti-O-Fe and Fe-O-Fe, contributing to the enhanced floatability.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2021)

添加到收藏夹

Article Engineering, Chemical

New insights into the mixed anionic/cationic collector adsorption on ilmenite and titanaugite: An in situ ATR-FTIR/2D-COS study

Liping Luo et al.

Summary: In this study, the co-adsorption behavior of SHA and DDA in the ilmenite-titanaugite flotation system was deeply investigated using in-situ ATR-FTIR, 2D-COS, and XPS. The results showed that the best flotation separation performance could be achieved at pH 8-9 with a SHA/DDA molar ratio of 6:1. The in-situ ATR-FTIR combined with 2D-COS revealed the characteristic sequential adsorption and interaction of SHA and DDA, which was further confirmed by XPS analysis.

MINERALS ENGINEERING (2021)

添加到收藏夹

Article Engineering, Chemical

Study on the flotation behavior and interaction mechanism of ilmenite with mixed BHA/NaOL collector

Yuankai Xu et al.

Summary: The study demonstrated that the mixed BHA/NaOL collector performed better in improving the floatability of ilmenite in the presence of lead ions compared to single BHA and NaOL collectors. Through measurements and analysis of surface properties, it was confirmed that the mixed collectors exhibited advantages in adsorption amount and surface properties.

MINERALS ENGINEERING (2021)

添加到收藏夹

Article Chemistry, Physical

Flotation and co-adsorption of mixed collectors octanohydroxamic acid/sodium oleate on bastnaesite

Yanbo Xu et al.

JOURNAL OF ALLOYS AND COMPOUNDS (2020)

添加到收藏夹

Article Chemistry, Physical

Structure, rheological and responsive properties of a new mixed viscoelastic surfactant system

Andrey Shibaev et al.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2020)

添加到收藏夹

Article Engineering, Chemical

Selective co-adsorption of a novelmixed collector ontomagnesite surface to improve the flotation separation of magnesite from dolomite

Jin Yao et al.

POWDER TECHNOLOGY (2020)

添加到收藏夹

Article Engineering, Chemical

Particle-bubble interaction energies for particles with physical and chemical heterogeneities

Allan Gomez-Flores et al.

MINERALS ENGINEERING (2020)

添加到收藏夹

Article Engineering, Chemical

New insights into lead ions activation for microfine particle ilmenite flotation in sulfuric acid system: Visual MINTEQ models, XPS, and ToF-SIMS studies

Shaojun Bai et al.

MINERALS ENGINEERING (2020)

添加到收藏夹

Article Engineering, Chemical

A novel miscible collector DDA-2-octanol-kerosene: Properties and flotation performance

Xiaoxiao Qiao et al.

MINERALS ENGINEERING (2020)

添加到收藏夹

Article Engineering, Chemical

Synergistic effect of mixed DDA/surfactants collectors on flotation of quartz

An Liu et al.

MINERALS ENGINEERING (2020)

添加到收藏夹

Article Engineering, Chemical

Comparative studies of flotation and adsorption of Pb(II)/benzohydroxamic acid collector complexes on ilmenite and titanaugite

Shuai Fang et al.

POWDER TECHNOLOGY (2019)

添加到收藏夹

Article Engineering, Chemical

Study on the activation mechanism of lead ions in wolframite flotation using benzyl hydroxamic acid as the collector

Cheng Liu et al.

MINERALS ENGINEERING (2019)

添加到收藏夹

Article Chemistry, Physical

The role of a fatty alcohol in improving calcium minerals flotation with oleate

LEv O. Filippov et al.

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS (2019)

添加到收藏夹

Article Chemistry, Applied

Interfacial Behavior of Anionic/Cationic Flotation Collectors in Mixed Aqueous Solutions and Their Effect on Flotation Recovery of Quartz

Savas Ozun et al.

JOURNAL OF SURFACTANTS AND DETERGENTS (2019)

添加到收藏夹

Article Chemistry, Physical

Effect of acidified water glass on the flotation separation of scheelite from calcite using mixed cationic/anionic collectors

Liuyang Dong et al.

APPLIED SURFACE SCIENCE (2018)

添加到收藏夹

Article Chemistry, Multidisciplinary

Study on the activation mechanism of lead ions in the flotation of ilmenite using benzyl hydroxamic acid as collector

Qingyou Meng et al.

JOURNAL OF INDUSTRIAL AND ENGINEERING CHEMISTRY (2018)

添加到收藏夹

Article Chemistry, Physical

Molecular arrangement of starch, Ca2+ and oleate ions in the siderite-hematite-quartz flotation system

Haiqing Hao et al.

JOURNAL OF MOLECULAR LIQUIDS (2018)

添加到收藏夹

Article Engineering, Chemical

Adsorption of Pb(II)/benzohydroxamic acid collector complexes for ilmenite flotation

Shuai Fang et al.

MINERALS ENGINEERING (2018)

添加到收藏夹

Article Engineering, Chemical

Non-polar oil assisted DDA flotation of quartz I: Interfacial interaction between dodecane oil drop and mineral particle

An Liu et al.

INTERNATIONAL JOURNAL OF MINERAL PROCESSING (2017)

添加到收藏夹

Article Engineering, Chemical

The activation mechanism of lead ions in the flotation of ilmenite using sodium oleate as a collector

Pan Chen et al.

MINERALS ENGINEERING (2017)

添加到收藏夹

Article Engineering, Chemical

Adsorption behavior of mixed cationic/anionic surfactants and their depression mechanism on the flotation of quartz

Li Wang et al.

POWDER TECHNOLOGY (2016)

添加到收藏夹

Article Metallurgy & Metallurgical Engineering

Effect and mechanism of octanol in cassiterite flotation using benzohydroxamic acid as collector

Lei Sun et al.

TRANSACTIONS OF NONFERROUS METALS SOCIETY OF CHINA (2016)

添加到收藏夹

Article Engineering, Chemical

New insights into the dodecylamine adsorption on scheelite and calcite: An adsorption model

Zhiyong Gao et al.

MINERALS ENGINEERING (2015)

添加到收藏夹

Article Engineering, Chemical

Flotation and adsorption of muscovite using mixed cationic-nonionic surfactants as collector

Li Wang et al.

POWDER TECHNOLOGY (2015)

添加到收藏夹

Article Engineering, Chemical

Adsorption mechanism of mixed collector systems on hematite flotation

A. Vidyadhar et al.

MINERALS ENGINEERING (2012)

添加到收藏夹

Article Metallurgy & Metallurgical Engineering

Adsorption mechanism of mixed salicylhydroxamic acid and tributyl phosphate collectors in fine cassiterite electro-flotation system

Qin Wen-qing et al.

JOURNAL OF CENTRAL SOUTH UNIVERSITY (2012)

添加到收藏夹

Article Engineering, Chemical

Adsorption and contact angle of single and binary mixtures of surfactants on apatite

H Sis et al.

MINERALS ENGINEERING (2003)

添加到收藏夹

Article Engineering, Chemical

Improving froth characteristics and flotation recovery of phosphate ores with nonionic surfactants

H Sis et al.

MINERALS ENGINEERING (2003)

添加到收藏夹

© Peeref 2019-2024. All rights reserved.