☆ 4.6 Article

Conceptual Design and Simulation-Based Optimization of Indirect Extractive Distillation Processes Considering Preconcentration for Separating Ternary Azeotropic Systems

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2023)

相关参考文献

注意：仅列出部分参考文献，下载原文获取全部文献信息。

Article Engineering, Environmental

Investigation on energy-saving extractive distillation for recovering ethanol and 1,4-dioxane from wastewater

Qingqing Rui et al.

Summary: Energy-saving extractive distillation method is proposed for separating ethanol and 1,4-dioxane from industrial effluent. Ethylene glycol (EG) is chosen as entrainer in direct extractive distillation, and dimethyl sulfoxide (DMSO) is used in the indirect extractive distillation (IED) process. Heat integration and heat pump technologies are employed to reduce energy consumption. The IED-DMSO process combined with heat integration achieves the best performance, with significant reductions in total annual cost, energy consumption, CO2 emissions, and entropy generation compared to the IED-EG process.

PROCESS SAFETY AND ENVIRONMENTAL PROTECTION (2023)

添加到收藏夹

Article Engineering, Chemical

Multi-objective optimization of the intensified extractive distillation with side-reboiler for the recovery of ethyl acetate and methanol from wastewater

Ao Yang et al.

Summary: This study investigates the recovery of ethyl acetate (EtAC) and methanol (MeOH) from wastewater using three different extractive distillation processes: triple-column ED (TCED), four-column ED (FCED), and energy-intensified TCED with side-reboiler (TCED-SR). The processes are conceptually designed and optimized using multi-objective particle swarm optimization with total annual cost (TAC), CO2 emission, and process route index (PRI) as objectives. TCED-SR provides the best economic and environmental performances, with the lowest TAC and CO2 emission. FCED is recommended in places with strict safety regulations, although it has higher TAC and CO2 emission compared to TCED-SR.

SEPARATION AND PURIFICATION TECHNOLOGY (2023)

添加到收藏夹

Article Engineering, Chemical

Control of heat-integrated indirect triple-column extractive distillation for separating ternary azeotropic mixture tetrahydrofuran-ethyl acetate-water

Shuangshuang Zhu et al.

Summary: Most of the current research on extractive distillation focuses on direct sequence extractive distillation (DED), while there is limited information on the design and control of indirect sequence extractive distillation (IED). This study examines the control performance of a heat-integrated IED for the separation of tetrahydrofuran (THF)/ethyl acetate (EtAc)/water. Three control strategies (CS 1, CS 2, and CS 3) are developed and compared, with CS 3 showing the best ability to maintain the purity of all three products close to the desired specification, even under feed flow and composition disturbances.

SEPARATION AND PURIFICATION TECHNOLOGY (2023)

添加到收藏夹

Article Engineering, Environmental

Design and optimisation of novel hybrid side-stream reactive-extractive distillation for recovery of isopropyl alcohol and ethyl acetate from wastewater

Ao Yang et al.

Summary: In this study, a novel side-stream double-column reactive-extractive distillation (SS-DCRED) was developed for the recovery of isopropanol (IPA) and ethyl acetate (EA) from wastewater. Compared to previous methods, the SS-DCRED achieved significant improvements in total energy consumption, total cost, and environmental performance.

CHEMICAL ENGINEERING JOURNAL (2023)

添加到收藏夹

Article Engineering, Chemical

Design and Optimization of Hybrid Reactive-Extractive Distillation for Ternary Azeotropic Separation: A Case Considering the Effect of Side Reactions

Zong Yang Kong et al.

Summary: Hybrid reactive-extractive distillation (RED) is a popular method for separating azeotropic mixtures by combining chemical reaction and physical azeotropic separation. However, recent studies have shown that side reactions in the hydration of ethylene oxide to form ethylene glycol can significantly increase the total energy consumption and total annual cost (TAC) of RED. These increases are attributed to larger column size, low operating pressure, and expensive cooling refrigerant. It is important for future RED studies to consider the potential side reactions.

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2023)

添加到收藏夹

Article Green & Sustainable Science & Technology

Towards sustainable separation of the ternary azeotropic mixture based on the intensified reactive-extractive distillation configurations and multi-objective particle swarm optimization

Ao Yang et al.

Summary: This study proposes a novel approach for the separation of ethanol/tert-butanol/water ternary azeotropic mixture. Two processes, double-column reactive-extractive distillation (DCRED) and reactive-extractive dividing wall column (REDWC), are developed using kinetic and thermodynamic analysis and optimized with a multi-objective particle swarm optimization algorithm. The evaluation based on cost, emissions, and efficiency shows that both processes have significant improvements compared to the conventional method.

JOURNAL OF CLEANER PRODUCTION (2022)

添加到收藏夹

Article Engineering, Chemical

The evolution of process design and control for ternary azeotropic separation: Recent advances in distillation and future directions

Zong Yang Kong et al.

Summary: This review summarizes various special distillation techniques for the separation of ternary azeotropic mixtures and provides recommendations for future studies.

SEPARATION AND PURIFICATION TECHNOLOGY (2022)

添加到收藏夹

Article Engineering, Chemical

Energy-efficient recovery of tetrahydrofuran and ethyl acetate by triple-column extractive distillation: entrainer design and process optimization

Ao Yang et al.

Summary: An energy-efficient triple-column extractive distillation process is developed for recovering tetrahydrofuran and ethyl acetate from industrial effluent. Through a rigorous hierarchical design procedure and heat integration, the process shows improved process economics.

FRONTIERS OF CHEMICAL SCIENCE AND ENGINEERING (2022)

添加到收藏夹

Article Engineering, Environmental

Design and eco-efficiency analysis of sustainable extractive distillation process combining preconcentration and solvent recovery functions for separating the tetrahydrofuran/ethanol/water ternary multi-azeotropic mixture

Chao Wang et al.

Summary: Designing a sustainable three-column extractive distillation process is of great significance for the efficient separation of ternary multi-azeotropic mixtures with high single component content. The integration of preconcentration and solvent recovery functions improves eco-efficiency, reduces CO2 emissions, and achieves economic cost savings. The process also demonstrates higher thermodynamic efficiency compared to other separation schemes.

PROCESS SAFETY AND ENVIRONMENTAL PROTECTION (2022)

添加到收藏夹

Article Engineering, Chemical

Intensification and analysis of extractive distillation processes with preconcentration for separating ethyl acetate, isopropanol and water azeotropic mixtures

Xue Jian et al.

Summary: Ethyl acetate and isopropanol are efficiently separated from a dilute solution during the production of ampicillin sodium through extractive distillation processes and intensified processes with heat integration and heat pump. These processes have shown significant energy and cost saving effects.

SEPARATION AND PURIFICATION TECHNOLOGY (2022)

添加到收藏夹

Article Computer Science, Interdisciplinary Applications

Multi-objective optimization and comparison of the entrainer-assisted pressure-swing distillation and extractive distillation separation sequences for separating a pressure-insensitive binary azeotrope

Yutao Qin et al.

Summary: This study investigates the performance of entrainer-assisted pressure-swing distillation (EAPSD) in separating pressure-insensitive azeotropes. The results show that the heat-integrated high-low sequence (HLS) outperforms the low-high sequence (LHS) in terms of cost and CO2 emission.

COMPUTERS & CHEMICAL ENGINEERING (2022)

添加到收藏夹

Article Engineering, Chemical

Effect of Entrainer Thermodynamic Properties on the Separation of Ternary Mixtures Containing Two Minimum Boiling Azeotropes by Extractive Distillation

Yasen Dai et al.

Summary: This study investigates the effects of different entrainers on the separation process of ternary mixtures in extractive distillation. The results show that the selection of entrainers should not solely rely on relative volatility and should consider thermodynamic properties and possible thermal integration schemes. The study provides insights for the screening of entrainers and process design in extractive distillation processes.

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2022)

添加到收藏夹

Article Engineering, Chemical

Process improvement for three-column extractive distillation by feed split

Cong Duan et al.

Summary: This article introduces a three-column extractive distillation process for separating azeotropic components at a dilute feed condition, and proposes an innovative method of feed splitting to save energy. The results show that most three-column extractive distillation processes can save energy by feed split and can be used in conjunction with other energy-saving methods.

SEPARATION AND PURIFICATION TECHNOLOGY (2022)

添加到收藏夹

Article Engineering, Chemical

Conceptual design of sustainable extractive distillation processes combining preconcentration and extractive distillation functions for separating ternary multi-azeotropic mixture

Chao Wang et al.

Summary: In this study, an efficient three-column extractive distillation process (TCED-IDC) was designed for separating ternary multi-azeotropic mixtures with a large content of one component. The energy and economic advantages of the TCED-IDC processes were demonstrated through two case studies.

CHEMICAL ENGINEERING SCIENCE (2022)

添加到收藏夹

Article Engineering, Chemical

Design and optimization for the separation of tetrahydrofuran/isopropanol/water using heat pump assisted heat-integrated extractive distillation

Yinggui Xu et al.

Summary: This study focuses on the separation of a ternary mixture using extractive distillation, with dimethyl sulfoxide as the optimal solvent. By introducing vapor recompressed heat pump technology and heat integration, significant energy savings were achieved. Direct extractive distillation was found to be better than indirect extractive distillation, with double-heat pump assisted direct extractive distillation showing the best performance in energy conservation and cost reduction.

SEPARATION AND PURIFICATION TECHNOLOGY (2021)

添加到收藏夹

Article Engineering, Chemical

Design and comparison of energy-saving double column and triple column reactive-extractive hybrid distillation processes for ternary multi-azeotrope dehydration

Chao Wang et al.

Summary: This study developed energy-saving reactive-extractive hybrid distillation processes for the purification and recovery of ethyl acetate and EtOH from wastewater containing a multi-azeotrope. Through optimization, the results showed that the hybrid processes significantly reduced process costs and CO2 emissions compared to traditional methods.

SEPARATION AND PURIFICATION TECHNOLOGY (2021)

添加到收藏夹

Article Engineering, Chemical

Investigation of energy-saving thermally coupled extractive distillation alternatives with different liquid side-stream for a quaternary azeotropic system

Zhishan Zhang et al.

Summary: This study established seven alternative thermally coupled extractive distillation configurations to optimize the separation efficiency of the acetone/methanol/butanone/tert-butanol system by introducing liquid side-streams. The intensified configurations showed good performance in energy-saving, TAC, and CO2 emissions, with the double-side-stream configuration being the optimal option.

SEPARATION AND PURIFICATION TECHNOLOGY (2021)

添加到收藏夹

Article Engineering, Chemical

Design and Control of an Alternative Bioethanol Purification Process via Reactive Distillation from Fermentation Broth

Devrim B. Kaymak

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2019)

添加到收藏夹

Article Engineering, Chemical

Design and Control of an Alternative Process for Biobutanol Purification from ABE Fermentation

Devrim B. Kaymak

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2019)

添加到收藏夹

Article Thermodynamics

Energy-saving thermally coupled ternary extractive distillation process by combining with mixed entrainer for separating ternary mixture containing bioethanol

Yongteng Zhao et al.

ENERGY (2018)

添加到收藏夹

Article Engineering, Chemical

Extractive Distillation Optimization Using Simulated Annealing and a Process Simulation Automation Server

Xiao-Ling Yang et al.

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2018)

添加到收藏夹

Article Biotechnology & Applied Microbiology

Comparison of extractive distillation separation sequences for acetonitrile/methanol/benzene multi-azeotropic mixtures

Chao Wang et al.

JOURNAL OF CHEMICAL TECHNOLOGY AND BIOTECHNOLOGY (2018)

添加到收藏夹

Article Computer Science, Interdisciplinary Applications

Design of an energy-efficient side-stream extractive distillation system

Salvador Tututi-Avila et al.

COMPUTERS & CHEMICAL ENGINEERING (2017)

添加到收藏夹

Article Thermodynamics

Vapor-Liquid Equilibria Measurement of (Methanol plus Ethanenitrile plus Bis(trifluoromethylsulfonyl) Imide)-Based Ionic Liquids at 101.3 kPa

Yuxin Zhang et al.

JOURNAL OF CHEMICAL AND ENGINEERING DATA (2016)

添加到收藏夹

Article Engineering, Chemical

Criterion of the energy effectiveness of extractive distillation in the partially thermally coupled columns

Elena Anokhina et al.

CHEMICAL ENGINEERING RESEARCH & DESIGN (2015)

添加到收藏夹

Article Engineering, Chemical

Design/optimization of energy-saving extractive distillation process by combining preconcentration column and extractive distillation column

Yi An et al.

CHEMICAL ENGINEERING SCIENCE (2015)

添加到收藏夹

Article Engineering, Chemical

Energy-Efficient Extractive Distillation Process by Combining Preconcentration Column and Entrainer Recovery Column

Kai Liang et al.

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2014)

添加到收藏夹

Article Thermodynamics

Conceptual design of an internally heat integrated propylene-propane splitter

Z. Olujic et al.

ENERGY (2006)

添加到收藏夹

Article Thermodynamics

Vapor-liquid equilibria of binary and ternary mixtures of benzene, cyclohexane, and chlorobenzene at 40.0 kPa and 101.3 kPa

MP Rolemberg et al.

JOURNAL OF CHEMICAL AND ENGINEERING DATA (2001)

添加到收藏夹

© Peeref 2019-2024. All rights reserved.