Peanut protein concentrate: Production and functional properties as affected by processing

Peanut protein concentrate (PPC) was isolated from fermented and unfermented defatted peanut flour by isoelectric precipitation and physical separation procedures. PPC was dried by spray or vacuum drying. PPC powders from each drying technique were evaluated for proximate composition and functional properties (protein solubility, water/oil binding capacity, emulsifying capacity, foaming capacity and viscosity) along with defatted peanut flour and soy protein isolate as references. PPC contained over 85% protein versus 50% protein in the defatted peanut flour used as raw material for PPC production. PPC had a solubility profile similar to that of peanut flour, with minimum solubility observed at pH 3.5-4.5 and maximum solubility at pH 10 and higher. Roasting of peanut reduced all functional properties of defatted peanut flour while fermentation had the reverse effect. The type of drying significantly affected the functional properties of PPC. Spray dried PPCs exhibited better functional properties, particularly emulsifying capacity and foaming capacity, than vacuum oven dried PPC. Spray dried PPCs also showed comparable oil binding and foaming capacity to commercially available soy protein isolate (SPC). At equivalent concentrations and room temperature, PPC suspension exhibited lower viscosity than soy protein isolate (SPI) suspensions. However, upon heating to 90 degrees C for 30 min, the viscosity of PPC suspension increased sharply. Results obtained from this study suggest that the PPC could be used in food formulations requiring high emulsifying capacity, but would not be suitable for applications requiring high water retention and foaming capacity. PPC could be a good source of protein fortification for a variety of food products for protein deficient consumers in developing countries as well as a functional ingredient for the peanut industry. The production of PPC could also add value to defatted peanut flour, a low value by-product of peanut oil production. (c) 2006 Elsevier Ltd. All rights reserved.