Effect of controlled κ-casein hydrolysis on rheological properties of acid milk gels

An experimental method based on the controlled chymosin-induced kappa-casein hydrolysis of milk was proposed to modify micellar reactivity. Milk samples with a degree of kappa-casein hydrolysis of 19, 35, and 51% were obtained. The physicochemical properties of partially converted casein micelles were determined. The net negative charge of casein micelles was reduced with increasing degree Of kappa-casein hydrolysis and a small but significant decrease in hydrodynamic diameter and micellar hydration were noted. Dynamic low amplitude oscillatory rheology was used to monitor the rheological properties of acid milk gels (GDL) made with partially chymosin-hydrolyzed milks in comparison with those of strictly acid and rennet gels. An increase in the gelation pH value was observed with increasing the degree of kappa-casein hydrolysis. The moduli values (G' and G) reached 2 h after the point of gel were, for all degrees of hydrolysis tested, significantly higher than those of strictly rennet and acid gels. Comparison of changes in DeltaG'/Deltat with time indicated differences in gel formation that could be related to the increased values of G' obtained for acid gel made with chymosin-treated milk. At a given time after gelation (2 h), increasing the degree of kappa-casein hydrolysis in milk led also to an increase in the loss tangent and the serum holding capacity of acid milk gels suggesting a correlation between these two parameters.