Catalytic co-pyrolysis of switchgrass and polyethylene over HZSM-5: Catalyst deactivation and coke formation

Conducted in the presence of a zeolite catalyst such as HZSM-5, fast pyrolysis of biomass can promote the rejection of oxygen and the formation of aromatic hydrocarbons in the organic liquid products. Unfortunately, this pathway removes hydrogen from the already hydrogen deficient biomass starting material, limiting the yield of hydrocarbons and leading to coke formation which results in catalyst deactivation. Co-pyrolysis of biomass and a low cost hydrogen rich material such as waste plastic has been considered as one strategy for mitigating hydrogen-deficiency with an added benefit of disposing of waste plastics effectively. Previous work has shown an enhancement of aromatic yields when polyolefins were copyrolyzed with biomass over fresh HZSM-5, but studies on the effect of catalyst deactivation with repeated use of the catalyst are lacking. In this study, pyrolysis coupled with gas chromatography and mass spectrometry (py-GC/MS) with an external catalytic reactor was used to perform ex situ catalytic co-pyrolysis of switchgrass and polyethylene (1:1 w:w) in the presence of HZSM-5. The catalyst (similar to 15 mg) was exposed to similar to 1 mg biomass and/or plastic in a series of 30 or 60 pulsed experiments for a cumulative feedstock to catalyst ratio of 2:1 and 4:1, respectively. Results showed that the initial rate of catalyst deactivation (up to feed:catalyst 2:1), as measured by the decrease in production of aromatic hydrocarbons, was significantly decreased, estimated at only similar to 28% of the rate of deactivation that processing of switchgrass alone caused. However, over the continued use of the catalyst, up to a feed to catalyst ratio of 4:1, the rates of deactivation from the blended feedstock increased to near expected rates based on the rate of deactivation for the switchgrass and HDPE individually.