Oxygen Release and Its Effect on the Cycling Stability of LiNixMnyCozO2 (NMC) Cathode Materials for Li-Ion Batteries

Layered LiNixMnyCozO2 (NMC) is a widely used class of cathode materials with LiNi1/3Mn1/3Co1/3O2 (NMC111) being the most common representative. However, Ni-rich NMCs are more and more in the focus of current research due to their higher specific capacity and energy. In this work we will compare LiNi1/3Mn1/3Co1/3O2 (NMC111), LiNi0.6Mn0.2Co0.2O2 (NMC622), and LiNi0.8Mn0.1Co0.1O2 (NMC811) with respect to their cycling stability in NMC-graphite full-cells at different end-of-charge potentials. It will be shown that stable cycling is possible up to 4.4 V for NMC111 and NMC622 and only up to 4.0 V for NMC811. At higher potentials, significant capacity fading was observed, which was traced back to an increase in the polarization of the NMC electrode, contrary to the nearly constant polarization of the graphite electrode. Furthermore, we show that the increase in the polarization occurs when the NMC materials are cycled up to a high-voltage feature in the dq/dV plot, which occurs at similar to 4.7 V vs. Li/Li+ for NMC111 and NMC622 and at similar to 4.3 V vs. Li/Li+ for NMC811. For the latter material, this feature corresponds to the H2 -> H3 phase transition. Contrary to the common understanding that the electrochemical oxidation of carbonate electrolytes causes the CO2 and CO evolution at potentials above 4.7 V vs. Li/Li+, we believe that the observed CO2 and CO are mainly due to the chemical reaction of reactive lattice oxygen with the electrolyte. This hypothesis is based on gas analysis using On-line Electrochemical Mass Spectrometry (OEMS), by which we prove that all three materials release oxygen from the particle surface and that the oxygen evolution coincides with the onset of CO2 and CO evolution. Interestingly, the onsets of oxygen evolution for the different NMCs correlate well with the high-voltage redox feature at similar to 4.7 V vs. Li/Li+ for NMC111 and NMC622 as well as at similar to 4.3 V vs. Li/Li+ for NMC811. To support this hypothesis, we show that no CO2 or CO is evolved for the LiNi0.43Mn1.57O4 (LNMO) spinel up to 5 V vs. Li/Li+, consistent with the absence of oxygen release. Lastly, we demonstrate by the use of C-13 labeled conductive carbon that it is the electrolyte rather than the conductive carbon which is oxidized by the released lattice oxygen. Taking these findings into consideration, a mechanism is proposed for the reaction of released lattice oxygen with ethylene carbonate yielding CO2, CO, and H2O. (C) The Author(s) 2017. Published by ECS. All rights reserved.