☆ 4.6 Article

Large and Highly Selective and Permeable CHA Zeolite Membranes

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2023)

Related references

Note: Only part of the references are listed.

Article Nanoscience & Nanotechnology

In Situ Synthesis of Cation-Free Zirconia-Supported Zeolite CHA Membranes for Efficient CO2/CH4 Separation

Nana Wang et al.

Summary: Cation-free zirconosilicate zeolite CHA and thin zirconia-supported membranes were synthesized in situ in a fluoride-free gel for the first time. The use of a ZrO2/Al2O3 composite support prevented the transportation of aluminum from the support into the zeolite membranes. The cation-free zeolite CHA membranes were synthesized without the use of a fluorite source, demonstrating the green nature of the synthesis. The membrane thickness was only 1.0 μm. The best cation-free zeolite CHA membrane prepared by the green in situ synthesis exhibited a high CO2 permeance of 1.1 x 10-6 mol/(m2 s Pa) and a CO2/CH4 selectivity of 79 at 298 K and 0.2 MPa pressure drop for an equimolar CO2/CH4 mixture.

ACS APPLIED MATERIALS & INTERFACES (2023)

Add to Collection

Article Engineering, Chemical

Industrially relevant CHA membranes for CO2/CH4 separation

Liang Yu et al.

Summary: The study evaluated single channel tubular zeolite CHA membranes with excellent permeability and selectivity for industrially relevant gas mixtures. The membranes showed low SF6 permeance and high CO2 permeance, exhibiting potential for industrial separation of CO2 from gas mixtures.

JOURNAL OF MEMBRANE SCIENCE (2022)

Add to Collection

Article Chemistry, Applied

Mass transport of CO2 over CH4 controlled by the selective surface barrier in ultra-thin CHA membranes

Mojtaba Sinaei Nobandegani et al.

Summary: This study experimentally investigated the adsorption and mass transport of CO2 and CH4 in CHA zeolite. Large and well-defined CHA crystals were prepared for adsorption studies, and adsorption isotherms were measured to estimate adsorption parameters. Permeation experiments with a defect-free CHA membrane also showed high selectivity for CO2 and CH4 under specific conditions.

MICROPOROUS AND MESOPOROUS MATERIALS (2022)

Add to Collection

Article Engineering, Environmental

Zeolite membrane process for industrial CO2/CH4 separation

Mojtaba Sinaei Nobandegani et al.

Summary: Zeolite membrane processes showed significantly higher selectivity and permeance compared to polymeric membrane processes for biogas upgrading, resulting in lower cost and electricity consumption, as well as more compact design.

CHEMICAL ENGINEERING JOURNAL (2022)

Add to Collection

Article Engineering, Chemical

The origin of the surface barrier in nanoporous materials

Jonas Hedlund et al.

Summary: The study found that surface barriers in MFI and CHA membranes may be a surface diffusion process with higher activation energy, with other possible mechanisms not ruled out. For pure components at low concentration in MFI zeolite, the barrier is proportional to the product of the molecular weight and heat of desorption; while at high concentration, the barriers of the components become more similar due to interaction effects.

JOURNAL OF MEMBRANE SCIENCE (2022)

Add to Collection

Article Engineering, Chemical

Exfoliation of lamellar SAPO-34 zeolite to nanosheets and synthesis of thin SAPO-34 membranes by a nanosheet-seeded secondary growth approach

Bin Wang et al.

Summary: High-aspect-ratio SAPO-34 nanosheets were successfully fabricated by exfoliation of lamellar SAPO-34 zeolite using a solvent-mediated freeze-thaw method. The nanosheets exhibited excellent performance in CO2 permeation and CO2/CH4 selectivity when used as thin membranes.

JOURNAL OF MEMBRANE SCIENCE (2022)

Add to Collection

Article Engineering, Environmental

A super-permeable and highly-oriented SAPO-34 thin membrane prepared by a green gel-less method using high-aspect-ratio nanosheets for efficient CO2 capture

Bin Wang et al.

Summary: In this study, tubular and preferentially oriented CHA-type SAPO-34 membranes were prepared by a gel-less method with few liquid wastes. These membranes exhibited good reproducibility and high efficiency. The presence of perpendicular, ordered, and short nanochannels in the SAPO-34 membrane facilitated fast CO2 permeation. The highly-oriented SAPO-34 membrane showed high CO2 permeances and selectivities, making it attractive for highly efficient CO2 capture.

CHEMICAL ENGINEERING JOURNAL (2022)

Add to Collection

Article Engineering, Chemical

Scalable fabrication of highly selective SSZ-13 membranes on 19-channel monolithic supports for efficient CO2 capture

Junjing Zhou et al.

Summary: This article describes a one-step secondary growth method using concentrated gel and vacuum seeding to prepare zeolite CHA (SSZ-13) membranes with high CO2/N2 selectivities on 19-channel monolithic supports. The membranes show improved packing density and mechanical strength compared to normal tubular and disc membranes. The synthesis procedure is scalable and large-area monolithic SSZ-13 membrane elements with high selectivities were fabricated. Temperature and pressure drop were found to affect the separation performance of the membranes. The membranes are promising for CO2 capture from natural gas and flue gas.

SEPARATION AND PURIFICATION TECHNOLOGY (2022)

Add to Collection

Article Engineering, Chemical

Efficient scale-up synthesis and hydrogen separation of hollow fiber DD3R zeolite membranes

Peng Du et al.

Summary: Efficient hydrogen separation is crucial from the cracked tail gas of ethylene plant. DD3R zeolite membranes were developed for this purpose, showing high selectivity and stability under harsh conditions. The efficient scale-up synthesis method led to the production of high-quality membranes suitable for industrial applications.

JOURNAL OF MEMBRANE SCIENCE (2021)

Add to Collection

Article Engineering, Chemical

Reproducible synthesis of all-silica CHA zeolite membranes in a homogeneous mother liquor

Xue Kong et al.

Summary: This study developed a new method for the synthesis of all-silica CHA membranes, which not only reduced material costs but also improved membrane performance.

SEPARATION AND PURIFICATION TECHNOLOGY (2021)

Add to Collection

Article Biochemistry & Molecular Biology

Gas Permeation Properties of High-Silica CHA-Type Zeolite Membrane

Yasuhisa Hasegawa et al.

Summary: In this study, a polycrystalline CHA-type zeolite layer with Si/Al = 18 was successfully formed on a porous alpha-Al2O3 tube, and the gas permeation properties were determined for various gases at different temperatures. The membrane exhibited selective permeation behavior based on molecular size, with high selectivities observed for N-2/SF6 and CO2/CH4. However, the CO2/N-2 selectivity was relatively low. These results suggest that the high-silica CHA-type zeolite membrane has potential for separating CO2 from CH4 through molecular sieving.

MEMBRANES (2021)

Add to Collection

Article Engineering, Chemical

High-performance 7-channel monolith supported SSZ-13 membranes for high-pressure CO2/CH4 separations

Yanmei Li et al.

Summary: This study successfully synthesized continuous SSZ-13 zeolite membranes on the inner surface of monolith supports for the first time, with higher packing density and mechanical strength. Inserting spacers was an effective way to reduce the negative impact of concentration polarization and improve separation performance of the membranes. Adding spacers significantly increased carbon dioxide permeance and CO2/CH4 selectivity under the same feed flow rate.

JOURNAL OF MEMBRANE SCIENCE (2021)

Add to Collection

Article Engineering, Chemical

Fast synthesis of thin SSZ-13 membranes by a hot-dipping method

Xiaoxue Tang et al.

Summary: In this study, sub-micron SSZ-13 membranes were successfully prepared using a hot-dipping method, demonstrating outstanding CO2-CH4 mixture separation performance. The method effectively prevented any undesirable changes to the seed layer, which may help in correlating membrane performance with seed layer properties.

JOURNAL OF MEMBRANE SCIENCE (2021)

Add to Collection

Article Engineering, Chemical

SSZ-13 zeolite membranes on four-channel α-Al2O3 hollow fibers for CO2 separation

Hua Liu et al.

Summary: High-silica CHA (SSZ-13) zeolite membranes show great potential for CO2 separation, but practical application is limited by high investment costs. In this study, SSZ-13 zeolite membranes were successfully synthesized on hollow fibers with different pore sizes, achieving good CO2/CH4 selectivity and CO2 permeance on membranes with 150 nm pores. Evaluation of gas permeation found that small molecules mainly pass through zeolitic pores, while larger molecules are more sensitive to non-zeolitic pores.

SEPARATION AND PURIFICATION TECHNOLOGY (2021)

Add to Collection

Article Engineering, Chemical

High performance SSZ-13 membranes prepared at low temperature

Heng'e Qiu et al.

JOURNAL OF MEMBRANE SCIENCE (2020)

Add to Collection

Article Engineering, Chemical

Synthesis of thin SAPO-34 zeolite membranes in concentrated gel

Ye Zhang et al.

JOURNAL OF MEMBRANE SCIENCE (2020)

Add to Collection

Article Chemistry, Applied

Ultra-thin MFI membranes with different Si/Al ratios for CO2/CH4 separation

Liang Yu et al.

MICROPOROUS AND MESOPOROUS MATERIALS (2019)

Add to Collection

Article Engineering, Chemical

Highly permeable and selective tubular zeolite CHA membranes

Liang Yu et al.

JOURNAL OF MEMBRANE SCIENCE (2019)

Add to Collection

Article Engineering, Chemical

Preparation of SSZ-13 membranes with enhanced fluxes using asymmetric alumina supports for N2/CH4 and CO2/CH4 separations

Shichao Song et al.

SEPARATION AND PURIFICATION TECHNOLOGY (2019)

Add to Collection

Article Chemistry, Physical

A novel method for fabrication of high-flux zeolite membranes on supports with arbitrary geometry

Liang Yu et al.

JOURNAL OF MATERIALS CHEMISTRY A (2019)

Add to Collection

Article Chemistry, Multidisciplinary

Highly Oriented Thin Membrane Fabrication with Hierarchically Porous Zeolite Seed

Xuguang Liu et al.

CRYSTAL GROWTH & DESIGN (2018)

Add to Collection

Article Chemistry, Physical

Highly permeable CHA membranes prepared by fluoride synthesis for efficient CO2/CH4 separation

Liang Yu et al.

JOURNAL OF MATERIALS CHEMISTRY A (2018)

Add to Collection

Article Engineering, Chemical

Preparation of defect-free DDR zeolite membranes by eliminating template with ozone at low temperature

Lin Wang et al.

JOURNAL OF MEMBRANE SCIENCE (2017)

Add to Collection

Article Engineering, Chemical

Optimization of membrane based nitrogen removal from natural gas

Burkhard Ohs et al.

JOURNAL OF MEMBRANE SCIENCE (2016)

Add to Collection

Article Chemistry, Multidisciplinary

Gas permeation and sorption properties of poly(amide-12-b-ethyleneoxide)(Pebax1074)/SAPO-34 mixed matrix membrane for CO2/CH4 and CO2/N2 separation

Hesamoddin Rabiee et al.

JOURNAL OF INDUSTRIAL AND ENGINEERING CHEMISTRY (2015)

Add to Collection

Article Engineering, Chemical

Preparation of steam-stable high-silica CHA (SSZ-13) membranes for CO2/CH4 and C2H4/C2H6 separation

Yihong Zheng et al.

JOURNAL OF MEMBRANE SCIENCE (2015)

Add to Collection

Article Engineering, Chemical

Preparation of graded silicalite-1 substrates for all-zeolite membranes with excellent CO2/H2 separation performance

Farid Akhtar et al.

JOURNAL OF MEMBRANE SCIENCE (2015)

Add to Collection

Article Engineering, Chemical

Physical aging and carbon dioxide plasticization of thin polyimide films in mixed gas permeation

Jianzhong Xia et al.

JOURNAL OF MEMBRANE SCIENCE (2014)

Add to Collection

Review Polymer Science

State-of-the-art membrane based CO2 separation using mixed matrix membranes (MMMs): An overview on current status and future directions

Mashallah Rezakazemi et al.

PROGRESS IN POLYMER SCIENCE (2014)

Add to Collection

Article Chemistry, Physical

High flux high-silica SSZ-13 membrane for CO2 separation

Nikolay Kosinov et al.

JOURNAL OF MATERIALS CHEMISTRY A (2014)

Add to Collection

Article Engineering, Chemical

Adsorption of CO2, CH4, and N2 on 8-, 10-, and 12-Membered Ring Hydrophobic Microporous High-Silica Zeolites: DDR, Silicalite-1, and Beta

Jiangfeng Yang et al.

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2013)

Add to Collection

Review Green & Sustainable Science & Technology

Current status and development of membranes for CO2/CH4 separation: A review

Yuan Zhang et al.

INTERNATIONAL JOURNAL OF GREENHOUSE GAS CONTROL (2013)

Add to Collection

Article Engineering, Chemical

Improving SAPO-34 membrane synthesis

Rongfei Zhou et al.

JOURNAL OF MEMBRANE SCIENCE (2013)

Add to Collection

Article Engineering, Chemical

Interfacially polymerized thin film composite membranes containing ethylene oxide groups for CO2 separation

Shichun Li et al.

JOURNAL OF MEMBRANE SCIENCE (2013)

Add to Collection

Article Chemistry, Multidisciplinary

Optimization of continuous phase in amino-functionalized metal-organic framework (MIL-53) based co-polyimide mixed matrix membranes for CO2/CH4 separation

Xiao Yuan Chen et al.

RSC ADVANCES (2013)

Add to Collection

Article Engineering, Chemical

Template removal from SAPO-34 crystals and membranes

Yanfeng Zhang et al.

JOURNAL OF MEMBRANE SCIENCE (2010)

Add to Collection

Article Engineering, Chemical

Multi-stage gas separation membrane processes used in post-combustion capture: Energetic and economic analyses

Li Zhao et al.

JOURNAL OF MEMBRANE SCIENCE (2010)

Add to Collection

Article Engineering, Chemical

Factors affect defect-free Matrimid® hollow fiber gas separation performance in natural gas purification

Guangxi Dong et al.

JOURNAL OF MEMBRANE SCIENCE (2010)

Add to Collection

Review Chemistry, Applied

Zeolite membranes - Recent developments and progress

Juergen Caro et al.

MICROPOROUS AND MESOPOROUS MATERIALS (2008)

Add to Collection

Article Engineering, Chemical

Materials dependence of mixed gas plasticization behavior in asymmetric membranes

T. Visser et al.

JOURNAL OF MEMBRANE SCIENCE (2007)

Add to Collection

Article Polymer Science

Matrimid polyimide membranes for the separation of carbon dioxide from methane

S. Sridhar et al.

JOURNAL OF APPLIED POLYMER SCIENCE (2007)

Add to Collection

Article Engineering, Environmental

Using molecular simulations for screening of zeolites for separation Of CO2/CH4 mixtures

R. Krishna et al.

CHEMICAL ENGINEERING JOURNAL (2007)

Add to Collection

© Peeref 2019-2024. All rights reserved.