☆ 4.5 Article

Lignin Recovery from Black Liquor Using Integrated UF/NF Processes and Economic Analysis

MEMBRANES (2023)

Related references

Note: Only part of the references are listed.

Article Engineering, Chemical

Isolation of Carboxylic Acids and NaOH from Kraft Black Liquor with a Membrane-Based Process Sequence

Silvia Maitz et al.

Membranes (2023)

Add to Collection

Article Engineering, Environmental

Effect of activated carbon nanoparticles on the performance of PES nanofiltration membranes to separate kraft lignin from black liquor

Manorma Sharma et al.

Summary: In this study, polyethersulfone nanofiltration membranes were prepared using activated carbon nanoparticles (AC) and evaluated for separating lignin from black liquor (BL). The addition of AC improved membrane properties such as water permeability and surface hydrophilicity. 0.1% AC-based membranes showed the highest flux and lignin rejection for BL filtration, with excellent water permeability recovery after cleaning. Optimization tests revealed that the best performance was achieved at specific temperature, pressure, and pH conditions. This study establishes a new application for AC-based NF membranes in lignin separation with reduced fouling.

JOURNAL OF WATER PROCESS ENGINEERING (2023)

Add to Collection

Article Energy & Fuels

Separation and recovery of lignin and hydrocarbon derivatives from cardboard

Giorgio Tofani et al.

Summary: This study demonstrates the feasibility of separating and recovering lignin and hydrocarbon derivatives from the waste stream of alkali extraction of recycled cardboard using acid precipitation. The procedure involves reducing pH levels and analyzing solid fractions to determine chemical composition and amount of precipitate. The recovered lignin showed similar characteristics to commercial lignin, while the hydrocarbon derivatives had a wide molecular weight range. Despite low extraction efficiency, the potential industrial value of recovering lignin from cardboard is significant.

BIOMASS CONVERSION AND BIOREFINERY (2022)

Add to Collection

Article Chemistry, Multidisciplinary

Multiple linear regression to predict the brightness of waste fibres mixtures before bleaching

Giorgio Tofani et al.

Summary: This study aims to develop a multiple linear regression model that correlates brightness and fibre composition of waste paper to determine in advance whether it can achieve the intended brightness. The model is validated and consistent, but measured brightness values are lower than expected, possibly due to differences between the reference fibre mixtures and waste paper pulp.

CHEMICAL PAPERS (2022)

Add to Collection

Article Green & Sustainable Science & Technology

Fractionation of black liquor using ZnO nanoparticles/PES ultrafiltration membranes: Effect of operating variables

Manorma Sharma et al.

Summary: Four types of ZnO-based polyethersulfone membranes were used to fractionate industrial black liquor into hemicellulose and lignin rich streams, with membranes containing 0.5% ZnO concentration showing the best performance. Optimal conditions at 60°C were suggested for minimal fouling and higher separation efficiency.

JOURNAL OF CLEANER PRODUCTION (2022)

Add to Collection

Article Biochemistry & Molecular Biology

Low-Molecular-Weight Lignin Recovery with Nanofiltration in the Kraft Pulping Process

Mariona Battestini Vives et al.

Summary: This study evaluates the use of nanofiltration for the separation and concentration of low-molecular-weight lignin from ultrafiltration permeate. The results show that nanofiltration process can produce a concentrated lignin fraction.

MEMBRANES (2022)

Add to Collection

Article Chemistry, Multidisciplinary

Optimization of hemicellulose recovery from black liquor using ZnO/PES ultrafiltration membranes in crossflow mode

Manorma Sharma et al.

Summary: Black liquor, a by-product of the pulp and paper industry, contains valuable biopolymers like lignin and hemicelluloses. This study successfully recovered hemicelluloses from black liquor using ZnO/ polyethersulfone ultrafiltration membrane, providing a new pathway for resource recovery.

JOURNAL OF INDUSTRIAL AND ENGINEERING CHEMISTRY (2022)

Add to Collection

Article Engineering, Chemical

Lignin separation from black liquor by mixed matrix polysulfone nanofiltration membrane filled with multiwalled carbon nanotubes

Manorma et al.

Summary: Carbon nanotubes/polysulfone mixed matrix membranes were developed for lignin separation from black liquor, with 0.5% CNT membranes showing a balance between permeate flux and lignin rejection. Chemical cleaning can fully recover initial flux of CNT-based membranes without affecting their rejection behavior.

SEPARATION AND PURIFICATION TECHNOLOGY (2021)

Add to Collection

Article Environmental Sciences

Membrane Filtration Opportunities for the Treatment of Black Liquor in the Paper and Pulp Industry

Olenka Jibaja Valderrama et al.

Summary: Black liquor, a by-product of the kraft pulping process, requires costly treatment to avoid environmental and financial implications. Nanofiltration is being studied as a promising alternative to recycle cooking chemicals, but the development of pH-stable membranes is crucial for industrial-scale operation. Membrane A shows higher potential for treating black liquor due to its competitive permeate flux and high rejection of organic components and salts.

WATER (2021)

Add to Collection

Article Chemistry, Multidisciplinary

Understanding the Effect of Precipitation Process Variables on Hardwood Lignin Characteristics and Recovery from Black Liquor

Raisa Carmen Andeme Ela et al.

ACS SUSTAINABLE CHEMISTRY & ENGINEERING (2020)

Add to Collection

Review Agricultural Engineering

Lignin materials for adsorption: Current trend, perspectives and opportunities

Nontipa Supanchaiyamat et al.

BIORESOURCE TECHNOLOGY (2019)

Add to Collection

Article Agricultural Engineering

Kraft lignin biorefinery: A perspective

Jianjun Hu et al.

BIORESOURCE TECHNOLOGY (2018)

Add to Collection

Review Agricultural Engineering

Lignin valorization for the production of renewable chemicals: State-of-the-art review and future prospects

Leichang Cao et al.

BIORESOURCE TECHNOLOGY (2018)

Add to Collection

Article Chemistry, Multidisciplinary

Graphene Oxide Membranes in Extreme Operating Environments: Concentration of Kraft Black Liquor by Lignin Retention

Fereshteh Rashidi et al.

ACS SUSTAINABLE CHEMISTRY & ENGINEERING (2017)

Add to Collection

Article Thermodynamics

A novel biorefinery integration concept for lignocellulosic biomass

Karhan Ozdenkci et al.

ENERGY CONVERSION AND MANAGEMENT (2017)

Add to Collection

Article Agricultural Engineering

Purification and concentration of lignin from the spent liquor of the alkaline oxidation of woody biomass through membrane separation technology

K. Servaes et al.

INDUSTRIAL CROPS AND PRODUCTS (2017)

Add to Collection

Review Chemistry, Multidisciplinary

Membranes for Kraft black liquor concentration and chemical recovery: Current progress, challenges, and opportunities

Nikita S. Kevlich et al.

SEPARATION SCIENCE AND TECHNOLOGY (2017)

Add to Collection

Article Forestry

Solvent screening for the fractionation of industrial kraft lignin

Antoine Duval et al.

HOLZFORSCHUNG (2016)

Add to Collection

Review Biochemistry & Molecular Biology

Membrane Technology for the Recovery of Lignin: A Review

Daniel Humpert et al.

MEMBRANES (2016)

Add to Collection

Article Agricultural Engineering

Softwood kraft lignin: Raw material for the future

Goran Gellerstedt

INDUSTRIAL CROPS AND PRODUCTS (2015)

Add to Collection

Article Engineering, Chemical

Process performance in lignin separation from softwood black liquor by membrane filtration

A. Arkell et al.

CHEMICAL ENGINEERING RESEARCH & DESIGN (2014)

Add to Collection

Article Engineering, Chemical

Flux behavior in clarification of chicory juice by high-shear membrane filtration: Evidence for threshold flux

Jianquan Luo et al.

JOURNAL OF MEMBRANE SCIENCE (2013)

Add to Collection

Review Engineering, Chemical

Effects of pH and salt on nanofiltration-a critical review

Jianquan Luo et al.

JOURNAL OF MEMBRANE SCIENCE (2013)

Add to Collection

Article Engineering, Chemical

Concentration and purification of lignin in hardwood kraft pulping liquor by ultrafiltration and nanofiltration

Ann-Sofi Jonsson et al.

CHEMICAL ENGINEERING RESEARCH & DESIGN (2008)

Add to Collection

Article Agricultural Engineering

Physico-chemical characterization of lignins from different sources for use in phenol-formaldehyde resin synthesis

A. Tejado et al.

BIORESOURCE TECHNOLOGY (2007)

Add to Collection

Article Engineering, Chemical

Processing of black liquors by UF/NF ceramic membranes

A Dafinov et al.

DESALINATION (2005)

Add to Collection

© Peeref 2019-2024. All rights reserved.