☆ 4.5 Article

Homoepitaxial growth of 3-inch single crystalline AlN boules by the physical vapor transport process

FRONTIERS IN MATERIALS (2023)

Related references

Note: Only part of the references are listed.

Article Chemistry, Multidisciplinary

Realizing overgrowth in the homo-PVT process for 2 inch AlN single crystals

Qiyue Zhao et al.

Summary: In this study, 2 inch AlN single crystals were grown and promoted using the homogeneous physical vapor transport (PVT) method on AlN seeds. It was found that the large-size AlN crystal homo-PVT process is characterized by the growth of prismatic grains in a macroscopic 3-dimensional mode. Overgrowth plays a key role in the merging of grains under a lateral overgrown c-plane surface. By studying the control law of growth conditions through a combination of experiments and computational fluid dynamics (CFD) simulations, it was clarified that the effect of overgrowth depends on growth rate and its matching relation with temperature and pressure. The results showed that overgrowth can significantly improve the coherence of c-plane orientations and crystal quality, providing a foundation for quality promotion through iterative homo-PVT growth on large-size AlN seeds.

CRYSTENGCOMM (2022)

Add to Collection

Article Chemistry, Multidisciplinary

Toward Φ56 mm Al-Polar AlN Single Crystals Grown by the Homoepitaxial PVT Method

Danyang Fu et al.

Summary: In this study, crack-free and parasitic-free large Al-polar aluminum nitride single crystals were iteratively grown using the homoepitaxial physical vapor transport method. The experiments showed that stable growth of large Al-polar crystals with good structural quality and UV transparency was possible using a pure tungsten setup.

CRYSTAL GROWTH & DESIGN (2022)

Add to Collection

Article Chemistry, Multidisciplinary

Comparison of the Thermal Stress Behavior of AlN Single Crystal Growth on AlN and SiC Seeds via the Physical Vapor Transport Method through Three-Dimensional Numerical Modeling and Simulation

Yinting Zhao et al.

Summary: The study on the distribution of stress during growth of AlN crystals using different seeds found that in heteroepitaxial growth, there is a high von Mises stress layer and higher shear stress, requiring a certain crystal thickness to avoid cracking; whereas in homoepitaxial growth, von Mises stress evolves smoothly with slightly lower shear stress. Overall, whether using AlN or SiC seeds, the total shear stress steadily increases in the entire growth process of bulk AlN crystals, with a small difference between homoepitaxial and heteroepitaxial growth.

CRYSTAL GROWTH & DESIGN (2021)

Add to Collection

Article Crystallography

Influences of Powder Source Porosity on Mass Transport during AlN Crystal Growth Using Physical Vapor Transport Method

Danyang Fu et al.

Summary: A two-dimensional transport model was developed to investigate mass transport during bulk AlN crystal growth via the PVT process. It was found that the porosity of the powder source significantly affects the growth process, with lower porosity leading to more uniform growth rate but decreased sublimation and crystal growth rates.

CRYSTALS (2021)

Add to Collection

Review Materials Science, Multidisciplinary

Ultrawide-bandgap semiconductor AlN crystals: growth and applications

Ruixian Yu et al.

Summary: Ultrawide bandgap semiconductor materials such as aluminum nitride (AlN) have attracted worldwide attention in recent years for their excellent characteristics, and the physical vapor transport (PVT) method has become one of the most effective ways to grow bulk AlN crystals. AlN crystals have shown significant strategic value, especially in high-power electronic devices and deep UV applications.

JOURNAL OF MATERIALS CHEMISTRY C (2021)

Add to Collection

Article Crystallography

Modelling and simulation of oxygen transport during AlN crystal growth by the PVT method

Danyang Fu et al.

JOURNAL OF CRYSTAL GROWTH (2020)

Add to Collection

Article Crystallography

Influence of crucible shape on mass transport in AlN crystal growth by physical vapor transport process

Qikun Wang et al.

JOURNAL OF CRYSTAL GROWTH (2019)

Add to Collection

Article Crystallography

Optimization of total resolved shear stress in AlN single crystals homoepitaxially grown by physical vapor transport method

Qikun Wang et al.

JOURNAL OF CRYSTAL GROWTH (2019)

Add to Collection

Article Materials Science, Multidisciplinary

Characterization of 60 mm AlN Single Crystal Wafers Grown by the Physical Vapor Transport Method

Qikun Wang et al.

PHYSICA STATUS SOLIDI A-APPLICATIONS AND MATERIALS SCIENCE (2019)

Add to Collection

Review Nanoscience & Nanotechnology

Ultrawide-Bandgap Semiconductors: Research Opportunities and Challenges

J. Y. Tsao et al.

ADVANCED ELECTRONIC MATERIALS (2018)

Add to Collection

Article Chemistry, Multidisciplinary

Anisotropic Three-Dimensional Thermal Stress Modeling and Simulation of Homoepitaxial AlN Single Crystal Growth by the Physical Vapor Transport Method

Qikun Wang et al.

CRYSTAL GROWTH & DESIGN (2018)

Add to Collection

Article Crystallography

Hotzone design and optimization for 2-in. AlN PVT growth process through global heat transfer modeling and simulations

Z. H. Wang et al.

JOURNAL OF CRYSTAL GROWTH (2017)

Add to Collection

Article Engineering, Electrical & Electronic

Bulk AlN growth by physical vapour transport

C. Hartmann et al.

SEMICONDUCTOR SCIENCE AND TECHNOLOGY (2014)

Add to Collection

Review Physics, Applied

Properties of the state of the art of bulk III-V nitride substrates and homoepitaxial layers

Jaime A. Freitas

JOURNAL OF PHYSICS D-APPLIED PHYSICS (2010)

Add to Collection

Article Crystallography

Low-pressure HVPE growth of crack-free thick AlN on a trench-patterned AlN template

Yusuke Katagiri et al.

JOURNAL OF CRYSTAL GROWTH (2009)

Add to Collection

Article Materials Science, Multidisciplinary

The progress of AlN bulk growth and epitaxy for electronic applications

Stephan G. Mueller et al.

PHYSICA STATUS SOLIDI A-APPLICATIONS AND MATERIALS SCIENCE (2009)

Add to Collection

Article Physics, Applied

Self-separation of a thick AIN layer from a sapphire substrate via interfacial voids formed by the decomposition of sapphire

Yoshinao Kumagai et al.

APPLIED PHYSICS EXPRESS (2008)

Add to Collection

Article Crystallography

Homoepitaxial seeding and growth of bulk AlN by sublimation

Carsten Hartmann et al.

JOURNAL OF CRYSTAL GROWTH (2008)

Add to Collection

Article Crystallography

Structural and surface characterization of large diameter, crystalline AlN substrates for device fabrication

Sandra B. Schujman et al.

JOURNAL OF CRYSTAL GROWTH (2008)

Add to Collection

Article Crystallography

Large-area AlN substrates for electronic applications: An industrial perspective

Robert T. Bondokov et al.

JOURNAL OF CRYSTAL GROWTH (2008)

Add to Collection

Article Multidisciplinary Sciences

An aluminium nitride light-emitting diode with a wavelength of 210 nanometres

Y Taniyasu et al.

NATURE (2006)

Add to Collection

© Peeref 2019-2024. All rights reserved.