☆ 4.7 Article

Transient behavior of an industrial-scale coke oven: CFD modeling and simulation with a fully coupled heating and coking model

JOURNAL OF ANALYTICAL AND APPLIED PYROLYSIS (2023)

Related references

Note: Only part of the references are listed.

Article Energy & Fuels

Numerical analysis of NOx formation mechanisms and emission characteristics with different types of reactants dilution during MILD combustion of methane and coke oven gas

Ghufran Ali et al.

Summary: A numerical study was conducted to emulate MILD combustion conditions in industrial furnaces, investigating the effects of different reactants dilution on NOx formation mechanisms and emissions. The research found that fuel dilution is more effective in reducing NOx emissions compared to oxidizer dilution. Additionally, a critical oxygen percentage was identified for dividing MILD combustion into different regimes based on inlet temperature.

FUEL (2022)

Add to Collection

Article Green & Sustainable Science & Technology

Environmental and economical assessment of high-value utilization routes for coke oven gas in China

Ke Ren et al.

Summary: This study conducted an environmental and economic analysis of different coke oven gas (COG) utilization routes in China, and found that the COG-to-hydrogen route had the lowest environmental and economic impact. Compared to coal-based routes, COG-based routes significantly reduced energy consumption and carbon emissions. Optimizing industrial layout and promoting COG recycling can enhance environmental and economic benefits.

JOURNAL OF CLEANER PRODUCTION (2022)

Add to Collection

Article Energy & Fuels

Heat and mass transfer mechanism and control strategy of clean low carbon combustion technology in the novel-type coke oven flue with MILD combustion

Qian Xu et al.

Summary: This study applies the Technology of Mixed-Gas (TMG), Technology of Low-calorific Value Gas (TLVG), and Technology of Low Oxygen Combustion (TLOC) in the Novel-type Coke Oven Flue with MILD Combustion (MILD-NCOF), and adjusts the ratios of different gases to improve heat and mass transfer and achieve dual emission reduction of pollutants and carbon emissions. Results show the optimal mixing ratios for alpha, beta, and gamma, which can meet the standards of clean production and low-carbon environmental protection.

FUEL (2022)

Add to Collection

Article Environmental Sciences

Characterization and emission factors of carbonaceous aerosols originating from coke production in China

Ling Mu et al.

Summary: The study measured the emission factors of OC and EC from typical coking plants in Shanxi, China, and found that the emissions from fugitive emissions were significantly higher than those from flue gas. The technological conditions of coke production impact the emissions of OC and EC, while different charging methods and carbon isotope characteristics also play a role in investigating the sources of carbonaceous aerosols.

ENVIRONMENTAL POLLUTION (2021)

Add to Collection

Article Energy & Fuels

Thermal process and NO emission reduction characteristics of a new-type coke oven regenerator coupled with SNCR process

Yujie Zhao et al.

Summary: The new-type coke oven regenerator utilizes high-temperature waste heat and SNCR technology to achieve efficient reduction of NO emissions, while proposing a strategy combining multiple operating parameters to ensure compliance with emission standards.

FUEL (2021)

Add to Collection

Article Thermodynamics

Optimizing the coke oven process by adjusting the temperature of the combustion chambers

G. W. Farias Neto et al.

Summary: Metallurgical coke, a fuel and raw material for iron and steel industries, is obtained from coal. However, only 15% of global coal reserves have the necessary properties for metallurgical coke, making it expensive. Developing a rigorous model of the coke oven process is important for optimizing energy consumption and reducing fuel consumption, with potential efficiency improvements in the worldwide steel industry.

ENERGY (2021)

Add to Collection

Article Thermodynamics

4E analysis and tri-objective optimization of a triple-pressure combined cycle power plant with combustion chamber steam injection to control NOx emission

Iman Fakhari et al.

Summary: This study introduces a novel triple-pressure combined cycle power plant system with heat recovery technology and combustion chamber steam injection to reduce hazardous emissions. Through a comprehensive investigation of energy, exergy, economic, and environmental impacts, a tri-objective optimization is conducted to improve efficiency, lower costs, and reduce emissions.

JOURNAL OF THERMAL ANALYSIS AND CALORIMETRY (2021)

Add to Collection

Article Energy & Fuels

Performance of a novel-type of heat flue in a coke oven based on high-temperature and low-oxygen diffusion combustion technology

Qian Xu et al.

FUEL (2020)

Add to Collection

Article Green & Sustainable Science & Technology

Numerical study and design strategy for a low emission coke oven system using oxy-fuel combustion of coke oven gas

Zhenxing Li et al.

JOURNAL OF CLEANER PRODUCTION (2020)

Add to Collection

Article Thermodynamics

Investigation of the heat-recovery/non-recovery coke oven operation using a one-dimensional model

Rafal Buczynski et al.

APPLIED THERMAL ENGINEERING (2018)

Add to Collection

Review Chemistry, Multidisciplinary

Expressions for the Evaporation and Condensation Coefficients in the Hertz-Knudsen Relation

Aaron H. Persad et al.

CHEMICAL REVIEWS (2016)

Add to Collection

Article Green & Sustainable Science & Technology

Numerical study of air staging in a coke oven heating system

Jakub Poraj et al.

CLEAN TECHNOLOGIES AND ENVIRONMENTAL POLICY (2016)

Add to Collection

Article Energy & Fuels

3-D coupled CFD model of a periodic operation of a heating flue and coke ovens in a coke oven battery

Jacek Smolka et al.

FUEL (2016)

Add to Collection

Article Thermodynamics

CFD analysis of the thermal behaviour of heating walls in a coke oven battery

Jacek Smolka et al.

INTERNATIONAL JOURNAL OF THERMAL SCIENCES (2016)

Add to Collection

Article Thermodynamics

Numerical study of volatiles production, fluid flow and heat transfer in coke ovens

Wei Lin et al.

APPLIED THERMAL ENGINEERING (2015)

Add to Collection

Article Energy & Fuels

CFD model of the coal carbonization process

Lukasz Slupik et al.

FUEL (2015)

Add to Collection

Article Chemistry, Applied

CFD modeling of phase change and coke formation in petroleum refining heaters

Xue-Gang Li et al.

FUEL PROCESSING TECHNOLOGY (2015)

Add to Collection

Article Chemistry, Analytical

Three phase transient model of wet coal pyrolysis

Sylwia Polesek-Karczewska et al.

JOURNAL OF ANALYTICAL AND APPLIED PYROLYSIS (2015)

Add to Collection

Article Thermodynamics

3-D periodic CFD model of the heating system in a coke oven battery

Jacek Smolka et al.

INTERNATIONAL JOURNAL OF NUMERICAL METHODS FOR HEAT & FLUID FLOW (2014)

Add to Collection

Article Thermodynamics

Simulation of transport phenomena in coke oven with staging combustion

Ke Jin et al.

APPLIED THERMAL ENGINEERING (2013)

Add to Collection

Article Energy & Fuels

Enhanced NOx Reduction by Combined Staged Air and Flue Gas Recirculation in Biomass Grate Combustion

Ehsan Houshfar et al.

ENERGY & FUELS (2012)

Add to Collection

© Peeref 2019-2024. All rights reserved.