☆ 4.7 Article

Interaction of Gd2Si2O7 with CMAS melts for environmental barrier coatings

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2023)

Related references

Note: Only part of the references are listed.

Article Materials Science, Ceramics

Reaction between environmental barrier coatings material Er2Si2O7 and a calcia-magnesia-alumina-silica melt

Seung-Hyeon Kim et al.

Summary: The suitability of sintered erbium disilicate as an environmental barrier coating for gas turbine applications was evaluated through high-temperature corrosion tests with a synthetic CMAS melt. The two materials were found to chemically react and form an apatite phase, with the reaction layer thickness increasing with time.

CERAMICS INTERNATIONAL (2022)

Add to Collection

Article Materials Science, Multidisciplinary

Tunable corrosion resistance of rare-earth monosilicate to molten calcia-magnesia-aluminosilicate glass by RE-doping strategy

Gui Cao et al.

Summary: This study investigates the CMAS corrosion behavior of hot-pressed (Y1-xYbx)2SiO5 ceramics at 1573 K. The corrosion products consist of non-stoichiometric apatite and garnet, formed through dissolution-reprecipitation mechanism. The growth rate of apatite layer increases rapidly with prolonged corrosion time, resulting in rapid corrosion. Additionally, the measured thickness of apatite layer is much lower than the predicted value based on the optical basicity theory.

CORROSION SCIENCE (2022)

Add to Collection

Article Materials Science, Ceramics

High-temperature corrosion of spark plasma sintered Gd2SiO5 with volcanic ash for environmental barrier coatings

Seung-Hyeon Kim et al.

Summary: The hot corrosion behavior of gadolinium monosilicate (Gd2SiO5) with volcanic ash for environmental barrier coatings was evaluated. Sintered Gd2SiO5 was prepared through spark plasma sintering (SPS) method and evaluated for high-temperature corrosion resistance against volcanic ash. Chemical reactions were observed, causing partial dissolution of sintered Gd2SiO5 and formation of new crystal structure with increasing heat treatment time. High-temperature X-ray diffraction revealed corrosion reaction between Gd2SiO5 phase and the Ca component of volcanic ash, generating a new phase at 1300 degrees C.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2021)

Add to Collection

Article Materials Science, Ceramics

Development of oxide-based High temperature environmental barrier coatings for ceramic matrix composites via the slurry process

Kang N. Lee et al.

Summary: An advanced environmental barrier coating (EBC) for SiC based composites was developed using a slurry process, with Yb2Si2O7 and mullite chosen as base materials for the bond coat. Various sintering aids enabled sintering at high temperatures, and the coatings showed good oxidation resistance and stability in steam oxidation tests. Additionally, kinetic analysis revealed that oxidant permeation through the silica scale is the rate controlling factor for TGO growth rates.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2021)

Add to Collection

Article Materials Science, Ceramics

Crystallization behavior of air-plasma-sprayed ytterbium-silicate-based environmental barrier coatings

Eugenio Garcia et al.

Summary: A combination of characterization techniques was used to provide new understanding of the complex crystallization behavior of as-sprayed amorphous Yb2Si2O7-based EBCs. Different phases formed and transformed during crystallization, with an increase in porosity contributing to anomalous expansion. Guidelines for achieving phase-pure and dense EBCs free of vertical cracks are also provided based on this understanding.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2021)

Add to Collection

Article Materials Science, Ceramics

Corrosion behavior of calcium-magnesium-aluminosilicate (CMAS) on sintered Gd2SiO5 for environmental barrier coatings

Seung-Hyeon Kim et al.

Summary: The research demonstrates that Gd2SiO5 exhibits high-temperature corrosion behavior on CMAS, forming the Ca2Gd8(SiO4)(6)O-2 phase. With the increase of heat treatment time, the Ca2Gd8(SiO4)(6)O-2 particles in the reaction area show a thicker morphology.

JOURNAL OF THE AMERICAN CERAMIC SOCIETY (2021)

Add to Collection

Article Materials Science, Ceramics

In situ observation of environmental barrier coating against calcium-magnesium-alumina-silicate attack at elevated temperature

Haitang Yang et al.

Summary: This study systematically investigated the resistance of environmental barrier coating (EBC) to calcium-magnesium-alumina-silicate (CMAS) phase at different temperatures, as well as the erosion effect of CMAS phase on EBC. The combination of SEM and EDS provided guidance for the modification of EBC.

INTERNATIONAL JOURNAL OF APPLIED CERAMIC TECHNOLOGY (2021)

Add to Collection

Article Materials Science, Ceramics

Effects of crystal structure and cation size on molten silicate reactivity with environmental barrier coating materials

Jamesa L. Stokes et al.

JOURNAL OF THE AMERICAN CERAMIC SOCIETY (2020)

Add to Collection

Article Materials Science, Ceramics

A promising molten silicate resistant material: Rare-earth oxy-apatite RE9.33(SiO4)6O2 (RE = Gd, Nd or La)

Han Zhang et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2020)

Add to Collection

Article Materials Science, Ceramics

Resistance of pure and mixed rare earth silicates against calcium-magnesium-aluminosilicate (CMAS): A comparative study

Markus Wolf et al.

JOURNAL OF THE AMERICAN CERAMIC SOCIETY (2020)

Add to Collection

Article Materials Science, Multidisciplinary

General trend on the phase stability and corrosion resistance of rare earth monosilicates to molten calcium magnesium aluminosilicate at 1300 °C

Zhilin Tian et al.

CORROSION SCIENCE (2019)

Add to Collection

Article Materials Science, Ceramics

Corrosion of RE2Si2O7 (RE = Y, Yb, and Lu) environmental barrier coating materials by molten calcium-magnesium-alumino-silicate glass at high temperatures

Zhilin Tian et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2019)

Add to Collection

Article Materials Science, Ceramics

High-Temperature thermochemical interactions of molten silicates with Yb2Si2O7 and Y2Si2O7 environmental barrier coating materials

Jamesa L. Stokes et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2019)

Add to Collection

Article Materials Science, Ceramics

Influence of rare earth oxides on kinetics and reaction mechanisms in CMAS silicate melts

F. Perrudin et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2019)

Add to Collection

Article Materials Science, Ceramics

Thermochemical interactions between CMAS and Ca2Y8(SiO4)6O2 apatite environmental barrier coating material

Jake Sleeper et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2019)

Add to Collection

Article Materials Science, Ceramics

CMC jackets for metallic pipes - A novel approach to prevent the creep deformation of thermo-mechanically loaded metals

Carolin Spatz et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2018)

Add to Collection

Article Materials Science, Ceramics

Environmental-barrier coating ceramics for resistance against attack by molten calcia-magnesia-aluminosilicate (CMAS) glass: Part II, beta-Yb2Si2O7 and beta-Sc2Si2O7

Laura R. Turcer et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2018)

Add to Collection

Article Nanoscience & Nanotechnology

Towards multifunctional thermal environmental barrier coatings (TEBCs) based on rare-earth pyrosilicate solid-solution ceramics

Laura R. Turcer et al.

SCRIPTA MATERIALIA (2018)

Add to Collection

Article Materials Science, Ceramics

High-temperature interactions of desert sand CMAS glass with yttrium disilicate environmental barrier coating material

Valerie L. Wiesner et al.

CERAMICS INTERNATIONAL (2018)

Add to Collection

Article Materials Science, Multidisciplinary

Effects of disorder on optical and electron spin linewidths in Er3+,Sc3+:Y2SiO5

S. Welinski et al.

OPTICAL MATERIALS (2017)

Add to Collection

Article Materials Science, Ceramics

Corrosion behavior of volcanic ash and calcium magnesium aluminosilicate on Yb2SiO5 environmental barrier coatings

Byung-Koog Jang et al.

JOURNAL OF THE CERAMIC SOCIETY OF JAPAN (2017)

Add to Collection

Article Materials Science, Ceramics

Corrosion behavior of volcanic ash on sintered mullite for environmental barrier coatings

Byung-Koog Jang et al.

CERAMICS INTERNATIONAL (2017)

Add to Collection

Article Materials Science, Coatings & Films

Thermal behavior and mechanical properties of Y2SiO5 environmental barrier coatings after isothermal heat treatment

Byung-Koog Jang et al.

SURFACE & COATINGS TECHNOLOGY (2016)

Add to Collection

Article Materials Science, Coatings & Films

Molten silicate reactions with plasma sprayed ytterbium silicate coatings

Hengbei Zhao et al.

SURFACE & COATINGS TECHNOLOGY (2016)

Add to Collection

Article Materials Science, Ceramics

Properties of CMAS glass from desert sand

Narottam P. Bansal et al.

CERAMICS INTERNATIONAL (2015)

Add to Collection

Article Materials Science, Ceramics

Molecular dynamics simulation of the structure and properties for the CaO-SiO2 and CaO-Al2O3 systems

Ting Wu et al.

JOURNAL OF NON-CRYSTALLINE SOLIDS (2015)

Add to Collection

Article Materials Science, Ceramics

Joining of C/SiC composites by spark plasma sintering technique

Stefano Rizzo et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2014)

Add to Collection

Article Materials Science, Ceramics

Volcanic Ash-Induced Decomposition of EB-PVD Gd2Zr2O7 Thermal Barrier Coatings to Gd-Oxyapatite, Zircon, and Gd, Fe-Zirconolite

Peter Mechnich et al.

JOURNAL OF THE AMERICAN CERAMIC SOCIETY (2013)

Add to Collection

Article Materials Science, Ceramics

Thermal Expansion of Rare-Earth Pyrosilicates

Alberto J. Fernandez-Carrion et al.

JOURNAL OF THE AMERICAN CERAMIC SOCIETY (2013)

Add to Collection

Article Materials Science, Ceramics

Calcium-magnesium-aluminosilicate corrosion behaviors of rare-earth disilicates at 1400 °C

Jia Liu et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2013)

Add to Collection

Article Materials Science, Ceramics

High-Temperature Corrosion of EB-PVD Yttria Partially Stabilized Zirconia Thermal Barrier Coatings with an Artificial Volcanic Ash Overlay

Peter Mechnich et al.

JOURNAL OF THE AMERICAN CERAMIC SOCIETY (2011)

Add to Collection

Article Materials Science, Ceramics

Mechanical behavior of SiCf reinforced SiC composites with fiber coating - Stress alleviation in SiC fiber by soft coating layer

Kyuug Soon Jang et al.

JOURNAL OF THE CERAMIC SOCIETY OF JAPAN (2009)

Add to Collection

Article Materials Science, Ceramics

Rare earth silicate environmental barrier coatings for SiC/SiC composites and Si3N4 ceramics

KN Lee et al.

JOURNAL OF THE EUROPEAN CERAMIC SOCIETY (2005)

Add to Collection

Review Materials Science, Multidisciplinary

Emerging materials and processes for thermal barrier systems

CG Levi

CURRENT OPINION IN SOLID STATE & MATERIALS SCIENCE (2004)

Add to Collection

© Peeref 2019-2024. All rights reserved.