4.5 Article

Fatigue Assessment of Wire and Arc Additively Manufactured Ti-6Al-4V

Related references

Note: Only part of the references are listed.
Article Metallurgy & Metallurgical Engineering

Implementation of a viscoplastic substrate creep model in the thermomechanical simulation of the WAAM process

S. Springer et al.

Summary: The research focuses on implementing a viscoplastic creep model in the thermomechanical simulation of the wire arc additive manufacturing (WAAM) process for Ti-6Al-4 V structures. Experimental creep tests were conducted to examine short-term creep behavior, and a Norton-Bailey creep law was used to describe the base material's creep behavior. The implementation of the creep model improved the numerical estimation of distortion and residual stress state in the substrate, with a reduced maximum distortion of about 13% and potential for more accurate local residual stress estimation.

WELDING IN THE WORLD (2022)

Article Chemistry, Physical

Fatigue Failure from Inner Surfaces of Additive Manufactured Ti-6Al-4V Components

Joel de Jesus et al.

Summary: Selective laser melting (SLM) is an additive manufacturing process used for producing metallic components with complex geometries, but the poor surface finish and geometry effects can lead to surface stress concentration and reduced fatigue strength. This study found that specimens with internal channels had lower fatigue performance compared to solid samples, with crack initiation mainly from the internal surface, while the application of the Smith-Watson-Topper energy-based parameter was effective in predicting fatigue life.

MATERIALS (2021)

Article Chemistry, Physical

Defects in Electron Beam Melted Ti-6Al-4V: Fatigue Life Prediction Using Experimental Data and Extreme Value Statistics

Viktor Sandell et al.

Summary: Electron beam melting is an additive manufacturing method for metals that offers opportunities for waste reduction and design freedom, but may suffer from material defects leading to scatter in fatigue performance. This study shows that probabilistic modeling using XCT data can provide accurate and conservative estimates of fatigue life, and requires minimal material volume for calibration.

MATERIALS (2021)

Article Engineering, Mechanical

Fatigue of wire plus arc additive manufactured Ti-6Al-4V in presence of process-induced porosity defects

Emre Akgun et al.

Summary: The failure of additive manufactured titanium alloy Ti-6Al-4V is primarily attributed to process-induced defects rather than pore size. Embedded pores below approximately 85 µm threshold size can achieve wrought level fatigue performance.

INTERNATIONAL JOURNAL OF FATIGUE (2021)

Article Nanoscience & Nanotechnology

Effect of deposition strategies on fatigue crack growth behaviour of wire plus arc additive manufactured titanium alloy Ti-6Al-4V

Abdul Khadar Syed et al.

Summary: The influence of three different deposition strategies on the fatigue crack growth behavior of WAAM Ti-6Al-4V was studied. The oscillation build exhibited the lowest crack growth rates and behaved more similarly to an annealed microstructure compared to the other two deposition strategies.

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2021)

Article Engineering, Manufacturing

On the relationship between cutting forces and anisotropy features in the milling of LPBF Inconel 718 for near net shape parts

Jose David Perez-Ruiz et al.

Summary: The study found that LPBF parameters affect cutting forces and the anisotropy of alloys through theoretical and experimental analyses. An oblique cutting Taylor model was proposed to quantify the crystallographic effects on shear strength, taking into account tool geometry, tool position, and laser scanning strategy.

INTERNATIONAL JOURNAL OF MACHINE TOOLS & MANUFACTURE (2021)

Proceedings Paper Materials Science, Multidisciplinary

Wire arc additive manufacturing (WAAM): A new process to shape engineering materials

Sudhanshu Ranjan Singh et al.

Summary: Additive Manufacturing (AM) has revolutionized the direct formation of products by replacing traditional manufacturing methods and reducing material consumption. Wire arc additive manufacturing (WAAM) has gained recognition for its efficiency, high deposition rates, and various benefits, especially in manufacturing large components. Extensive research has been conducted to widen the applications of WAAM and improve material properties.

MATERIALS TODAY-PROCEEDINGS (2021)

Article Engineering, Mechanical

Fatigue strength assessment of as built AlSi10Mg manufactured by SLM with different build orientations

S. Beretta et al.

INTERNATIONAL JOURNAL OF FATIGUE (2020)

Article Nanoscience & Nanotechnology

A probabilistic Kitagawa-Takahashi diagram for fatigue strength assessment of cast aluminium alloys

R. Aigner et al.

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2019)

Review Materials Science, Multidisciplinary

Additive manufacturing of Ti6Al4V alloy: A review

Shunyu Liu et al.

MATERIALS & DESIGN (2019)

Article Thermodynamics

Inspection scheduling based on reliability updating of gas turbine welded structures

Armando Coro et al.

ADVANCES IN MECHANICAL ENGINEERING (2019)

Review Chemistry, Physical

Current Status and Perspectives on Wire and Arc Additive Manufacturing (WAAM)

Tiago A. Rodrigues et al.

MATERIALS (2019)

Article Nanoscience & Nanotechnology

Anisotropy of fatigue crack growth in wire arc additive manufactured Ti-6Al-4V

Yong Xie et al.

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2018)

Article Chemistry, Physical

Fatigue Behavior of Porous Ti-6Al-4V Made by Laser-Engineered Net Shaping

Seyed Mohammad Javad Razavi et al.

MATERIALS (2018)

Article Chemistry, Physical

Modification of a Defect-Based Fatigue Assessment Model for Al-Si-Cu Cast Alloys

Roman Aigner et al.

MATERIALS (2018)

Article Engineering, Mechanical

Fatigue performance of additive manufactured TiAl6V4 using electron and laser beam melting

Daniel Greitemeier et al.

INTERNATIONAL JOURNAL OF FATIGUE (2017)

Article Engineering, Mechanical

A comparison of fatigue strength sensitivity to defects for materials manufactured by AM or traditional processes

S. Beretta et al.

INTERNATIONAL JOURNAL OF FATIGUE (2017)

Article Nanoscience & Nanotechnology

Microporosity and statistical size effect on the fatigue strength of cast aluminium alloys EN AC-45500 and 46200

Martin Leitner et al.

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2017)

Article Materials Science, Multidisciplinary

Qualification of AM parts: Extreme value statistics applied to tomographic measurements

S. Romano et al.

MATERIALS & DESIGN (2017)

Article Materials Science, Multidisciplinary

Additive manufacturing of metals

Dirk Herzog et al.

ACTA MATERIALIA (2016)

Review Materials Science, Multidisciplinary

Metal Additive Manufacturing: A Review

William E. Frazier

JOURNAL OF MATERIALS ENGINEERING AND PERFORMANCE (2014)

Article Materials Science, Multidisciplinary

Microstructure and Mechanical Properties of Wire and Arc Additive Manufactured Ti-6Al-4V

Fude Wang et al.

METALLURGICAL AND MATERIALS TRANSACTIONS A-PHYSICAL METALLURGY AND MATERIALS SCIENCE (2013)

Article Engineering, Industrial

Investigation of the benefits of plasma deposition for the additive layer manufacture of Ti-6Al-4V

F. Martina et al.

JOURNAL OF MATERIALS PROCESSING TECHNOLOGY (2012)

Article Automation & Control Systems

Study of mechanical properties of AISI 316 stainless steel processed by selective laser melting, following different manufacturing strategies

Itziar Tolosa et al.

INTERNATIONAL JOURNAL OF ADVANCED MANUFACTURING TECHNOLOGY (2010)

Article Materials Science, Multidisciplinary

Additive manufacturing of Ti-6Al-4V components by shaped metal deposition: Microstructure and mechanical properties

Bernd Baufeld et al.

MATERIALS & DESIGN (2010)

Article Nanoscience & Nanotechnology

On the relationship between statistical distributions of defect size and fatigue life in 7050-T7451 thick plate and A356-T6 castings

Murat Tiryakioglu

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2009)

Article Materials Science, Multidisciplinary

Relationship between Defect Size and Fatigue Life Distributions in Al-7 Pct Si-Mg Alloy Castings

Murat Tiryakioglu

METALLURGICAL AND MATERIALS TRANSACTIONS A-PHYSICAL METALLURGY AND MATERIALS SCIENCE (2009)

Article Nanoscience & Nanotechnology

Statistical distributions for the size of fatigue-initiating defects in Al-7%Si-0.3%Mg alloy castings: A comparative study

Murat Tiryakioglu

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2008)

Article Nanoscience & Nanotechnology

On the size distribution of fracture-initiating defects in Al- and Mg-alloy castings

Murat Tiryakioglu

MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING (2008)