4.8 Article

Battery Thermal Runaway Fault Prognosis in Electric Vehicles Based on Abnormal Heat Generation and Deep Learning Algorithms

Related references

Note: Only part of the references are listed.
Article Thermodynamics

Experimental investigation on the characteristics of thermal runaway and its propagation of large-format lithium ion batteries under overcharging and overheating conditions

Zonghou Huang et al.

Summary: This study investigates the characteristics and mechanism of thermal runaway (TR) and its propagation in lithium-ion batteries induced by overcharging and overheating. Results show that TR induced by overcharging is more severe than that induced by overheating, with a constant critical thermal energy for fully charged batteries.

ENERGY (2021)

Article Electrochemistry

Multi-Mode Heat Transfer Simulations of the Onset and Propagation of Thermal Runaway in a Pack of Cylindrical Li-Ion Cells

Dhananjay Mishra et al.

Summary: This study investigates the onset and propagation of thermal runaway in a pack of Li-ion cells through multi-mode heat transfer simulations. It demonstrates the significant impact of interstitial material thermal conductivity and trigger cell position on thermal runaway propagation. Additionally, it suggests that trade-offs in these factors can help minimize the onset and propagation of thermal runaway in Li-ion battery packs.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2021)

Article Engineering, Electrical & Electronic

Load Current and State-of-Charge Coestimation for Current Sensor-Free Lithium-Ion Battery

Zhongbao Wei et al.

Summary: This study proposes a method for online load current and state-of-charge coestimation of lithium-ion batteries without the need for installing a current sensor. Experimental results show that the proposed method can accurately coestimate these parameters, which is insightful for reducing the structural complexity and cost of future LIB utilization.

IEEE TRANSACTIONS ON POWER ELECTRONICS (2021)

Article Chemistry, Physical

Thermal fault detection and localization framework for large format batteries

Sara Sattarzadeh et al.

Summary: Thermal fault diagnostics in large format pouch or prismatic cells pose challenges due to the two-dimensional nature of temperature distribution. A framework is proposed to optimize sensor locations and design filtering schemes for improved detection and isolation of thermal faults. This framework is validated through experimental and simulation studies on a commercial battery cell.

JOURNAL OF POWER SOURCES (2021)

Article Chemistry, Physical

Modeling of the overcharge behavior of lithium-ion battery cells protected by a voltage-switchable resistive polymer layer

A. A. Fedorova et al.

Summary: A novel approach using a voltage-switchable resistive polymer layer for overcharge protection of Li-ion batteries was reported. Simulation results showed that the battery protected by this layer has advantages in various charging modes, demonstrating the effectiveness of the protective layer with switchable resistance. This model is a powerful tool for material design and engineering tasks in LIB development.

JOURNAL OF POWER SOURCES (2021)

Article Engineering, Electrical & Electronic

Battery Fault Diagnosis for Electric Vehicles Based on Voltage Abnormality by Combining the Long Short-Term Memory Neural Network and the Equivalent Circuit Model

Da Li et al.

Summary: This article presents a novel battery fault diagnosis method that combines neural network and equivalent circuit model, utilizing modified adaptive boosting and pre-judging models to enhance accuracy and reliability. Considering driver behavior influence on battery systems, the method can assess potential failure risk and issue early thermal runaway warnings. Real-world operation data from China's National Monitoring and Management Center for New Energy Vehicles is used to verify the method's robustness and accuracy, showing precise fault diagnosis and thermal runaway cell location.

IEEE TRANSACTIONS ON POWER ELECTRONICS (2021)

Article Engineering, Electrical & Electronic

Case Study of an Electric Vehicle Battery Thermal Runaway and Online Internal Short-Circuit Detection

Wei Gao et al.

Summary: This paper analyzes the process of thermal runaway in a battery pack and identifies critical time points of fault signals. It proposes a simple and reliable method for diagnosing ISC based on cell voltage differences.

IEEE TRANSACTIONS ON POWER ELECTRONICS (2021)

Article Engineering, Electrical & Electronic

An accessible method of embedding fibre optic sensors on lithium-ion battery surface for in-situ thermal monitoring

Keith M. Alcock et al.

Summary: The study presents a proof of concept to evaluate the suitability of a mounting technique for fibre optic sensors to measure Lithium-ion Battery temperature. A new guide-tube technique proposed in the study significantly improves measurement accuracy, making it suitable for cell-level temperature monitoring applications.

SENSORS AND ACTUATORS A-PHYSICAL (2021)

Article Energy & Fuels

Experimental study on the influence of different heating methods on thermal runaway of lithium-ion battery

Qingsong Zhang et al.

Summary: Heating lithium-ion batteries with different State of Charge (SOC) can lead to thermal runaway, with the start temperature and energy required for thermal runaway decreasing with increasing SOC. The cylindrical heating rod provides better and more uniform heat transfer compared to the spring heating coil, resulting in higher battery temperatures.

JOURNAL OF ENERGY STORAGE (2021)

Article Energy & Fuels

Electro-thermal coupling model of lithium-ion batteries under external short circuit

Zeyu Chen et al.

Summary: This paper investigates the impact of temperature on battery electro-thermal behaviors under external short circuit (ESC) through experiments and establishes a novel electro-thermal coupling model for predicting the complex thermal and electrical properties of a battery under ESC. Simulation results demonstrate the effectiveness of the presented model.

APPLIED ENERGY (2021)

Review Energy & Fuels

The Importance of Optical Fibres for Internal Temperature Sensing in Lithium-ion Batteries during Operation

Markus S. Wahl et al.

Summary: This article discusses the thermal problems that arise during the use of lithium-ion batteries, as well as the importance of fiber Bragg grating sensors in directly measuring temperature within the battery cell.

ENERGIES (2021)

Article Engineering, Electrical & Electronic

Structural Analysis in Reconfigurable Battery Systems for Active Fault Diagnosis

Michael Schmid et al.

Summary: This article discusses the differences and advantages between conventional automotive battery systems and reconfigurable battery systems, focusing on fault isolation methods and algorithms in RBS. By experiment and structural analysis, a sensor set with optimal fault isolation properties was found, and a novel algorithm for efficiently calculating minimal structurally overdetermined subsystems for fault diagnosis was proposed.

IEEE TRANSACTIONS ON POWER ELECTRONICS (2021)

Article Engineering, Electrical & Electronic

Design of Parallel Resonant Switched-Capacitor Equalizer for Series-Connected Battery Strings

Lizhou Liu et al.

Summary: An automatic parallel resonant switched-capacitor equalizer is proposed to eliminate inrush current and increase balance speed by utilizing resonant switched-capacitors and parallel ReSC converters. The circuit controls all switches with a pair of complementary pulsewidth modulation signals at a fixed operational frequency. Simulation and experiments confirm the feasibility of the circuit, showing three times faster balance speed compared to traditional equalizers.

IEEE TRANSACTIONS ON POWER ELECTRONICS (2021)

Article Optics

Research on a laser ultrasonic visualization detection method for human skin tumors based on pearson correlation coefficient

Wei Zeng et al.

Summary: Skin tumors, a form of skin cancer, pose a serious threat to human health. Many organizations are studying methods to diagnose and monitor skin diseases by detecting skin characteristics. This study explores the feasibility of using laser-generated ultrasonic waves to detect human skin tumors, which proves to be a viable tool for tumor detection and characterization.

OPTICS AND LASER TECHNOLOGY (2021)

Article Energy & Fuels

Thermal runaway characteristics of a LiFePO4-based lithium-ion secondary battery using the laser-irradiation method

Sayoko Shironita et al.

Summary: The study investigated the safety of lithium-ion secondary batteries through laser irradiation heating, revealing the thermal runaway process induced by laser irradiation heating. The results showed that laser irradiation heating can generate a high power per unit area and lead to thermal runaway, which is comparable to heating with a ceramic heater.

JOURNAL OF ENERGY STORAGE (2021)

Article Energy & Fuels

Distributed thermal monitoring of lithium ion batteries with optical fibre sensors

Yifei Yu et al.

Summary: Real-time temperature monitoring is crucial for the safe operation of lithium-ion batteries, particularly for large pouch cells used in automotive or grid storage applications. A novel Rayleigh scattering based optical fibre sensing technology is proposed to provide distributed, real-time and accurate temperature measurement for li-ion pouch cells, showing significant improvement over traditional methods. The study demonstrates the importance of accurate temperature monitoring for the thermal behavior of pouch cells during operation.

JOURNAL OF ENERGY STORAGE (2021)

Article Computer Science, Artificial Intelligence

Study on the prediction of stock price based on the associated network model of LSTM

Guangyu Ding et al.

INTERNATIONAL JOURNAL OF MACHINE LEARNING AND CYBERNETICS (2020)

Article Automation & Control Systems

Online Fault Diagnosis of External Short Circuit for Lithium-Ion Battery Pack

Rui Xiong et al.

IEEE TRANSACTIONS ON INDUSTRIAL ELECTRONICS (2020)

Article Computer Science, Artificial Intelligence

Major-Minor Long Short-Term Memory for Word-Level Language Model

Kai Shuang et al.

IEEE TRANSACTIONS ON NEURAL NETWORKS AND LEARNING SYSTEMS (2020)

Review Chemistry, Physical

Mitigating Thermal Runaway of Lithium-Ion Batteries

Xuning Feng et al.

JOULE (2020)

Article Physics, Multidisciplinary

3D CNN-Based Speech Emotion Recognition Using K-Means Clustering and Spectrograms

Noushin Hajarolasvadi et al.

ENTROPY (2019)

Review Thermodynamics

A review of lithium ion battery failure mechanisms and fire prevention strategies

Qingsong Wang et al.

PROGRESS IN ENERGY AND COMBUSTION SCIENCE (2019)

Article Acoustics

Speech Emotion Classification Using Attention-Based LSTM

Yue Xie et al.

IEEE-ACM TRANSACTIONS ON AUDIO SPEECH AND LANGUAGE PROCESSING (2019)

Article Engineering, Electrical & Electronic

Long Short-Term Memory Recurrent Neural Network for Remaining Useful Life Prediction of Lithium-Ion Batteries

Yongzhi Zhang et al.

IEEE TRANSACTIONS ON VEHICULAR TECHNOLOGY (2018)

Article Computer Science, Information Systems

An Overview on Thermal Safety Issues of Lithium-ion Batteries for Electric Vehicle Application

Jianan Zhang et al.

IEEE ACCESS (2018)

Review Computer Science, Information Systems

Critical Review on the Battery State of Charge Estimation Methods for Electric Vehicles

Rui Xiong et al.

IEEE ACCESS (2018)

Review Green & Sustainable Science & Technology

A review of lithium-ion battery state of charge estimation and management system in electric vehicle applications: Challenges and recommendations

M. A. Hannan et al.

RENEWABLE & SUSTAINABLE ENERGY REVIEWS (2017)

Article Computer Science, Hardware & Architecture

ImageNet Classification with Deep Convolutional Neural Networks

Alex Krizhevsky et al.

COMMUNICATIONS OF THE ACM (2017)

Article Thermodynamics

Investigation of power battery thermal management by using mini-channel cold plate

Yutao Huo et al.

ENERGY CONVERSION AND MANAGEMENT (2015)

Article Automation & Control Systems

A Survey of Fault Detection, Isolation, and Reconfiguration Methods

Inseok Hwang et al.

IEEE TRANSACTIONS ON CONTROL SYSTEMS TECHNOLOGY (2010)

Article Engineering, Chemical

Adaptive process monitoring using efficient recursive PCA and moving window PCA algorithms

Jyh-Cheng Jeng

JOURNAL OF THE TAIWAN INSTITUTE OF CHEMICAL ENGINEERS (2010)

Article Computer Science, Artificial Intelligence

Design concept evaluation in product development using rough sets and grey relation analysis

Lian-Yin Zhai et al.

EXPERT SYSTEMS WITH APPLICATIONS (2009)

Article Engineering, Chemical

Adaptive multivariate statistical process control for monitoring time-varying processes

SW Choi et al.

INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH (2006)

Article Automation & Control Systems

Model-based fault-detection and diagnosis - status and applications

R Isermann

ANNUAL REVIEWS IN CONTROL (2005)

Article Computer Science, Artificial Intelligence

Random forests

L Breiman

MACHINE LEARNING (2001)

Article Electrochemistry

Thermal model of cylindrical and prismatic lithium-ion cells

TD Hatchard et al.

JOURNAL OF THE ELECTROCHEMICAL SOCIETY (2001)

Article Computer Science, Artificial Intelligence

Learning to forget: Continual prediction with LSTM

FA Gers et al.

NEURAL COMPUTATION (2000)