Effect of temperature on biogas yield increase and formation of refractory COD during thermal hydrolysis of waste activated sludge

Thermal hydrolysis (TH) increases the anaerobic biodegradability of waste activated sludge (WAS), but also refractory organic and nutrient return load to a wastewater treatment plant (WWTP). This could lead to an increase in effluent chemical oxygen demand (COD) of the WWTP. The aim of this study was to investigate the trade-off between increase in biogas production through TH and anaerobic digestion and increase in refractory COD in dewatered sludge liquors at different temperatures of TH in lab-scale. WAS was thermally hydrolyzed in temperature range of 130-170 degrees C for 30 min to determine its biomethane potential (BMP). After BMP test, sludge was dewatered and sludge liquor was aerated in Zahn-Wellens test to determine its non-biodegradable soluble COD known as refractory soluble COD (sCOD(ref)). With increasing temperature in the range of 130-170 degrees C, BMP of WAS increased by 1727%, while sCOD(ref) increased by 3.9-8.4%. Dewaterability was also enhanced through relative increase in cake solids by 12-30%. A conversion factor was defined through mass balance to relate sCOD(ref) to volatile solids of raw WAS. Based on the conversion factor, expected increase in effluent CODs of six WWTPs in Berlin were predicted to be in the range of 2-15 mg/L after implementation of TH at different temperatures. It was concluded that with a slight decrease in temperature, formation of sCOD(ref) could be significantly reduced, while still benefiting from a substantial increase in biogas production and dewaterability improvement. (C) 2019 Elsevier Ltd. All rights reserved.